N7578L

HISTORY OF FLIGHT

On July 17, 1998, about 1431 eastern daylight time, a Piper PA-31-310, N7578L, registered to a private individual, operating as a Title 14 CFR Part 91 personal flight, crashed after takeoff from Kendall-Tamiami Executive Airport (TMB), Miami, Florida. Visual meteorological conditions prevailed and no flight plan was filed. The airplane was destroyed, and the commercial-rated pilot, the sole occupant, was fatally injured. The flight was originating at the time of the accident.

According to the FAA control tower communication tapes, N7578L called for, and was given, clearance for takeoff and a downwind departure from runway 9L at about 1429. About 2 minutes later, a radio transmission from N7578L that included some unintelligible words, but clearly mentioned the words, "we got a.." and "engine", was made.

The airplane impacted the terrain about 1 mile northeast of the geographic center of the airport in heavy underbrush of scrub pines and palmetto. Several witnesses observed the airplane in its departure turn at an altitude below 100 feet agl, and hearing unusual engine sounds seconds before the accident. An aircraft mechanic, standing abeam of the departure runway, observed most of the takeoff roll and the airplane's gyrations before it went out of sight into the brush. He states that he was first attracted to the sound of a rough running engine, and saw that the left engine was trailing black smoke. He states that the airplane never got above about 150 feet agl, and its airspeed seemed slow. The last thing he observed was a rapid left roll, and a marked pitch down of the nose.

PERSONNEL INFORMATION

Although requested of the family numerous times, the pilot's logbooks were not recovered. At the time of the pilot's application for his second class medical certificate on December 5, 1996, he listed his flight time as 6,700 hours. According to numerous sources from the airport community at TMB, the pilot tried to maintain the airplane as economically as possible, and in fact, did some of his own maintenance.

AIRCRAFT INFORMATION

The airplane and engine logbooks were not located after the accident. An interview with the owner/operator of a local engine repair station revealed that the right engine had undergone a recent major overhaul by the repair station and certified "zero time" on November 4, 1997. The owner/operator of the repair station was told at that time that the left engine would be brought in for a major overhaul in "a couple of months". The pilot had previously mentioned to a friend and co-worker that the left engine was 400 hours over factory recommended time for overhaul.

METEOROLOGICAL INFORMATION

Visual meteorological conditions prevailed at the time of the accident. Meteorological information is contained in this report under Weather Information.

WRECKAGE AND IMPACT INFORMATION

Examination of the crash site revealed the airplane crashed on county property adjacent to Boystown of Florida, a foster care facility, at coordinates, N25.39.65 and W80.25.07 or about 1.26 miles/072 degrees from the airport's center. The site roughly corresponds to a point in the departure traffic pattern off runway 9L at TMB about the 110-degree point of a 180-degree down wind departure turn. The wreckage path and tree and foliage scars indicated the twin engine airplane was rolling left about its longitudinal axis and was about 70 degrees nose down, inverted, near wings level with both propellers turning, at ground impact. The nose of the airplane was crushed along a line from about 2 feet behind the two pilots' seats on the top of the airplane to about 1 foot aft of the rudder pedals on the bottom. Wing leading edges were deformed backward and toward the top of the airplane and matched the fuselage crush line. From the point of initial impact, where the propellers and nose pieces were found buried in the hard packed sand, the airplane bounced, became upright, and slid tail first to its final resting place. Extensive wing trailing edge damage was done as the wings encountered small trees in the backward slide. The aft fuselage from the third cabin window, aft sustained little damage. There was no explosion or fire, although the site revealed heavy fuel leakage. The wreckage came to rest heading about 030 degrees. Everything forward of the crush line, including the instrument panel and radios was demolished. Both engines were broken away from their mounts and both propellers had broken away at the crankshaft flange. The site smelled strongly of aviation fuel.

Postcrash examination of the wreckage revealed that the pilot's seatbelt was buckled and had been cut by rescue personnel. The shoulder harness had not been used. All flight control surfaces were present at impact. Complete continuity of primary flight control path was impossible due to damage to the cockpit floor/center section area. Aileron control rods had separated at the wing bellcrank, but control cable path was confirmed from center section to the bellcrank. Rudder and elevator controls were confirmed intact and operable from the control surfaces to about the rear baggage compartment. Rudder cables were attached at the pedals. Measured at the rudder trim jackscrew, the rudder was trimmed for 1/4 of full range for nose right. Similarly measured, the elevator was trimmed for 1/2 of full nose up range for nose up. Landing gear and flaps were retracted and cowl flaps were closed. Both fuel cells, (main and auxiliary) on both wings had been compromised and contained no fuel. The cockpit fuel management panel was found with left engine selected to left main tank, right engine to right main, and crossfeed selector to "off". The left and right fuel filters were removed and a small amount of fuel in each was tested negatively for water content, however, the left filter cartridge contained aluminum and brown colored sediment, and the cartridge housing had sediment crusted at it's bottom and was showing evidence of its own corrosion. The right fuel filter cartridge contained a smaller amount of the same sediment and the cartridge housing held a small amount in it's bottom.

Postcrash examination of the engines and propellers revealed that both propellers were turning at impact and both broke off at the crankshaft flange. The left propeller showed all three blades bent aft from a point about 10 inches outward from the hub. Two blades bent aft about 15 degrees and the third blade about 40 degrees. All showed chordwise scoring on the front of the blades, no marking on the aft sides, and little leading edge damage. The spinner was crushed against the hub, which was bent at about a 15 degree angle and showed less rotational scoring that the right spinner. The blades showed signs of surface corrosion. The right propeller had one blade broken at its retention radius with little blade bending and heavy leading edge scoring, and two blades bent aft, one about 20 degrees from a point 10 inches from the hub, and the third about 45 degrees from its midspan point. The two bent blades had extensive rotational scoring on front and aft sides with heavy leading edge burnishing and scoring. The spinner was crushed against the hub, and showed moderate rotational scoring. The propeller appeared to have been recently overhauled. Both propellers were removed for further examination. Both propeller governors revealed no evidence of precrash malfunction.

Both engines had broken loose from their engine mounts, both exhaust systems and turbochargers had been displaced rearward, and the aft mounted accessories sustained severe crushing damage. Both drive trains were manually rotated and revealed no malfunctions of the rotating group, valve train, and accessory section. Both engine's spark plugs were checked for security and removed, revealing good compression in the proper firing order at all cylinders, and no cylinder wall scoring could be seen. The left engine spark plug electrodes showed a black coloration consistent with a rich fuel/air mixture combustion. The right engine spark plug electrodes showed the ash-brown coloration of a normal fuel/air mixture combustion, (Champion Spark Plugs Check-A-Plug chart AV-27). The ignition harnesses had been severed in several places, but the connections at the magneto and spark plug terminals were secure. The left engine magneto to engine timing could not be confirmed due to magneto impact damage. One magneto sustained a shattered housing and could not be field tested for spark. The other sustained a broken hold down clamp, and it tested good for spark at all six terminals. Both right engine magnetos also sustained impact damage that shattered their housings and precluded checking magneto to engine timing or testing for spark.

The fuel injection servos and induction systems for both engines were free of obstructions, and all engine compartment fuel lines were in place with connections secure. The fuel inlet filter screens for both servos were found properly installed and were free of contamination. The left servo was removed for further testing. Both engine driven fuel pumps showed no sign of precrash malfunction. The injector nozzles and all fuel feed and upper deck reference lines were found in place and all fittings and connections were secure. All nozzles and lines were then removed and found unobstructed. Both exhaust systems, although severely deformed, were unobstructed. The turbocharger wastegates showed no evidence of precrash malfunction. The turbochargers were removed for further testing.

MEDICAL AND PATHOLOGICAL INFORMATION

Postmortem examination and toxicological testing of the pilot was performed by Bruce A. Hyma, M.D. at the Medical Examiner's Department, Miami, Florida, and revealed cause of death to be blunt force trauma to head and chest. Their toxicology test results showed 9.5 percent saturation for carbon monoxide in the blood and a finding of "d...