N34TM

HISTORY OF FLIGHT

On May 27, 1999, at 1826 central daylight time, a Cessna 421B, N34TM, was destroyed when it impacted the ground approximately 1.6 miles northwest of the approach end of runway 12 at the Jefferson City Memorial Airport, Jefferson City, Missouri. The private pilot and three passengers received fatal injuries. The 14 CFR Part 91 flight had departed Poplar Bluff Municipal Airport (POF), Poplar Bluff, Missouri, at approximately 1730 en route to Jefferson City (JEF), Missouri. Visual meteorological conditions prevailed and the flight was on an IFR flight plan. The airplane was on the final segment of a visual approach to runway 12 when the pilot indicated he had a loss of power. The airplane was seen making a left turn to the northeast. It continued to roll and it impacted the ground in a nose low, inverted attitude.

Records indicate the pilot contacted the Federal Aviation Administration's (FAA) St. Louis Automated Flight Service Station (AFSS) at 1711 to obtain a weather brief and file a flight plan. The filed flight plan showed the flight was a direct flight from POF direct to JEF with a time en route of 45 minutes. Fuel on board was listed as 4.5 hours.

At 1820:09, N34TM contacted the JEF control tower. N34TM had been given a visual approach to runway 12 by approach control, and was instructed by the JEF control tower to enter the right traffic pattern for runway 12.

At 1823:24, N34TM reported entering the right downwind for runway 12. N34TM was sequenced as the number two aircraft for landing.

At 1824:20, N34TM acknowledged that he was cleared to land.

At 1825:47, N34TM reported, "Jeff Tower, N34TM, I've just lost power on the right engine, eh, left engine." No further radio transmissions were made by N34TM to the tower.

Witnesses reported seeing the airplane flying toward the airport. Then they reported seeing the airplane turn left to the north as it passed over highway 63. The witnesses reported the airplane's altitude was approximately 200 to 400 feet. They reported seeing the airplane's wings rock back and forth. They reported seeing the airplane wings banked approximately 90 degrees to the left. Then the airplane nosed over and impacted the ground.

One witness reported seeing white smoke coming from the belly of the airplane for one to two seconds. He reported seeing the airplane's wings wobble before it went into the sharp left bank. He reported it was approximately 20 seconds from the time that he saw the white smoke until it impacted the ground. He reported the landing gear was not extended.

One witness reported that he heard power being applied to the engines. He reported the airplane was in a left bank, and then it entered a "drastic upward climb" before nosing over and going straight down. He reported that he thought both engines were running.

The JEF airport manager, who was in the control tower at the time of the accident, reported the airplane, "... appeared to be north of the extended centerline and proceeding northbound at a low altitude. The aircraft appeared to be in a shallow left bank, and was approximately 1 mile northwest of the airport. The aircraft also appeared to level out once, but then returned to the shallow left turn, and continued to lose altitude. Within a few seconds the aircraft suddenly rolled into a steep left turn, (approximately 90 degrees) the nose pointed down to vertical, and the aircraft descended behind the treeline. We then observed smoke from that location."

The witnesses reported the airplane burst into flames immediately after impacting the ground.

PERSONNEL INFORMATION

The pilot was a private pilot with single and multi-engine land ratings, and an instrument rating. He held a Third Class medical certificate. The pilot's flight logbook was not obtained. An insurance form dated March 9, 1999, indicated the pilot had approximately 1,850 hours of total flight time and 850 hours of time in make and model aircraft.

The pilot purchased N34TM in 1997. The total hours on the airplane when he purchased the airplane was approximately 5303 hours. The airplane had been flown approximately 227 hours since the pilot purchased the airplane.

AIRCRAFT INFORMATION

The airplane was a twin engine Cessna 421B, serial number 421B-0965. The airplane seated eight and had a maximum gross weight of 7,450 pounds. The engines were 375 horsepower Continental GTSIO-520-H engines. The last annual inspection was conducted on March 15, 1999. The airplane had flown about 35 hours since the last inspection and had a total time of about 5,530 hours.

The annual inspection conducted on March 15, 1999, indicated the compression on the left engine was 80/64, 50, 67, 70, 69, and 62. The right engine compression was 80/64, 64, 71, 62, 66, and 68.

The left propeller logbook indicated that on May 18, 1999, the left propeller was removed from the left engine for repair. The logbook indicated that nicks to one of the blades were filed and the propeller was balanced. The propeller was re-installed on the airplane on May 24, 1999.

METEOROLOGICAL INFORMATION

The JEF weather at 1753 was reported as: Winds 000 at 6 knots, sky clear, visibility 10 miles, temperature 74 degrees Fahrenheit, dew point 46 degrees Fahrenheit, altimeter 30.10.

WRECKAGE AND IMPACT INFORMATION

The aircraft wreckage was located at coordinates N 42 degrees 36.786 minutes, W 92 degrees, 10.651 minutes. The location was approximately 1.6 nautical miles and 324 degrees from the approach end of runway 12. The terrain was a flat, hard packed field used for growing grass sod. The direction of the wreckage path was about 355 degrees. (See Wreckage Diagram and Photographs)

The left and right propellers were located at the initial impact site and were found on a line perpendicular to the wreckage path. The left propeller was found on the right side of the wreckage path, and the right propeller was found on the left side of the wreckage path. Both the left and right propellers were found 12 to 18 inches under the hard packed soil. Rotational paint transfer patterns from the propeller blades onto the hard packed soil were evident.

The left propeller blades exhibited chordwise scratching and leading edge polishing. The #3 blade exhibited blade polishing for more than a fourth of the blade. The #2 and #3 blade were bent aft.

The right propeller blades exhibited chordwise scratching and the #2 and #3 blades were bent aft. The #1 blade tip was curled aft with a slight bend aft. Both #2 and #3 blades exhibited blade polishing.

The fuselage, cockpit, and the left and right wings were destroyed by fire. All flight controls were found attached to their respective hinges. Control cables were traced throughout the wreckage to their respective hinges. Cable fractures exhibited "broom straw" features.

The left and right wingtip fuel tanks had impacted the terrain on the same line as the propellers. Fan shaped burn patterns in the direction of the wreckage path emanated from the impact marks made by the wingtip fuel tanks.

The on-site examination of the left engine revealed that the number two cylinder spark plugs' electrodes were damaged. The number two cylinder piston was broken and the piston pin was still attached to the piston rod.

MEDICAL AND PATHOLOGICAL INFORMATION

The autopsy on the pilot was performed at Office of the Medical Examiner, Columbia, Missouri.

A Forensic Toxicology Fatal Accident Report was prepared by the FAA Civil Aeromedical Institute. The report indicated the following results:

Carbon monoxide: Not performed

Cyanide: Not performed

No Ethanol detected in urine.

Ephedrine detected in liver fluid.

Pseudoephedrine detected in liver fluid.

Phenylopropanolamine detected in liver fluid.

Ephedrine detected in urine.

Pseudoephedrine detected in urine.

Phenylpropanolamine detected in urine.

Pseudoephedrine, ephedrine, and phenylpropanolamine are common ingredients in over-the-counter decongestants and diet pills.

TESTS AND RESEARCH

The left and right engines were examined at Teledyne Continental Motors. The inspection of the right engine revealed that it had received fire damage. No pre-existing engine deficiencies were noted.

The left engine examination revealed the following information:

1. Number two Piston part number SA 646303 was found broken. Pieces of this piston were recovered from the engine oil sump.

2. Number two piston pin aluminum plug ends were peened over.

3. Number 2 exhaust valve was broken at the lower stem to head transition area. The valve was part number AC 637781. Number two exhaust valve guide was checked with a go, no-go gage and found to be worn oversized at the lower inside bore. The guide was removed from the cylinder and found to be part number AC 643767P010. The lower end (cylinder combustion chamber) was oblong. The valve guide I.D. measured .460 inch and .480 inch respectively. Per TCM overhaul manual, the exhaust valve to guide clearance should be .003 to .0047 inch. The valve clearance in this valve guide was from .028 inch to .048 inch loose. (See Teledyne Continental Motors Airsafety Investigation Report)

The left and right engine turbochargers were examined by Allied Signal Aerospace. (See Allied Signal Aerospace Teardown Report)

The left and right propellers were examined at McCauley Propeller Systems. (See McCauley Teardown Report)

The National Transportation Safety Board (NTSB) Materials Laboratory examined the following aircraft parts:

Left Engine: #2 and #6 cylinder exhaust valve and valve guides; turbocharger assembly; and turbocharger wastegate manifold.

Right Engine: Turbocharger assembly; turbocharger wastegate manifold; exhaust tail pipe with shield mounted to structure; and a fuel line section.

The inspection revealed the following:

1. The fracture face of the #2 exhaust valve stem was consistent with a bending fatigue separation. Multip...