N306AW

HISTORY OF FLIGHT

On August 25, 2001, at 0111 central daylight time (cdt), a Boeing 737-3G7, N306AW, Flight 598, operated by America West Airlines, Inc. (AWA), sustained foreign object damage (FOD) to both engines during landing when it veered off the left side of runway 27 (9,500 feet by 150 feet, wet grooved asphalt) at the Kansas City International Airport (MCI), Kansas City, Missouri. The captain, first officer, three flight attendants, and 53 passengers were not injured. One passenger reported a minor injury. Airport Rescue and Fire Fighting (ARFF) personnel responded and confirmed there was no smoke, fire, or fuel coming from the airplane. An emergency evacuation was not conducted. The passengers were kept on board the airplane until a bus arrived to transport them to the terminal. The Title 14 Code of Federal Regulations Part 121 scheduled, domestic flight originated from Phoenix Sky Harbor International Airport (PHX), Phoenix, Arizona, on August 24, 2001, at 2025 mountain standard time (mst), and was en route to MCI. Instrument meteorological conditions prevailed at that time. The flight was on an IFR flight plan.

The captain and first officer reported for duty at PHX on August 24, 2001, at 1340 mst for the start of a two day trip, Trip 1050. Four flight legs were scheduled on August 24th. The first scheduled takeoff was at 1425 mst, and the final landing of the fourth leg of flight occurred at 0111 cdt at MCI. The flight crew's duty time was 10 hours and 38 minutes.

On August 24, 2001, the first three flight legs on Trip 1050 were completed without incident, and the airplane arrived back at PHX at 1948 mst at the completion of the third leg of flight. The scheduled departure time for Flight 598 was 2023 mst, and the actual departure time was 2025 mst.

The pilots were interviewed by America West Airlines (AWA) personnel, representatives of the Air Line Pilots Association, and by an inspector from the Federal Aviation Administration. The AWA report stated the following information:

"The first officer was acting as the Pilot Flying (PF). The aircraft was operating normally with the exception of the auto thrust system that was placarded inoperative under the provisions of the minimum equipment list (MEL). The weather was clear until approximately 30 minutes prior to landing when the flight began deviating around convective activity using onboard weather radar and vectors from Air Traffic Control (ATC). Several runway changes were assigned by ATC. The winds were updated to approximately from the West at 8 knots and the visibility was believed to have been reported between 6 and 8 miles. ATC offered Runway 27 and the crew accepted. The first officer briefed the captain on a visual approach 'backed up by the ILS.'

The aircraft was configured for a 'flaps 30' landing and the landing checklist was completed including the arming of the speed brakes.

During the approach, the flight encountered heavy rain decreasing to light or moderate rain approximately 6 miles from the runway. The captain reported the approach lights in sight approximately 2 miles from touchdown and reported the runway lights in sight almost immediately thereafter. Between 500 and 1,000 feet above touchdown, the captain advised the first officer that the flight management system (FMS) was indicating the winds to be from 320 degrees at 8 knots.

The captain described the weather conditions 'as advertised.' The first officer indicated that the visibility was worse than he had anticipated.

On short final, the wipers were turned on and the auto brakes were set to '2.'

The first officer reported that during the flare and landing, the runway appeared to absorb the light from the aircraft's landing lights and the runway was very black. Both pilots reported the touchdown to be normal except for the absence of the sensation of touchdown. The reversers were activated normally. The crew did not recall whether or not the reverser lights came on or if the speed brakes activated.

The first officer reported that sometime after the nose wheel was lowered to the runway, he saw the left-side runway lights entering his peripheral view indicating to him that the aircraft was tracking to the left while remaining parallel to the runway centerline. The captain attempted to assist the first officer by using the steering tiller.

The aircraft exited the left side of the runway. The first officer stowed the reversers. As soon as the aircraft came to a complete stop, the captain made a public address (PA) announcement commanding the passengers to 'Remain seated, the situation is under control.' The first officer notified ATC of the situation and requested the Airport Rescue and Fire Fighting (ARFF) equipment. After the ARFF crew reported no significant hazards, the captain started the Auxiliary Power Unit (APU) until the passengers could be deplaned using portable stairs." (See AWA report of pilots' statements)

The captain in a written statement reported the following:

"I was the Captain, non-flying pilot, on flight 598 (PHX-MCI) on the night of August 24, 2001. MCI had scattered thunderstorms and rain in the area. We were vectored to the ILS for runway 27, and on final approach experienced light to moderate rain with winds reported out of the west at eight knots. I saw the approach lights at approximately two miles from the runway and the runway lights immediately thereafter. The approach and landing appeared normal; however on touchdown, the aircraft shifted to the left side of the runway and ultimately partially exited the runway into the field, despite using right aileron, rudder, and tiller inputs. Once stopped, we contacted the tower and asked for emergency vehicles, and then notified the Company. Passengers were de-planed by emergency crews and aircraft control handed off the MCI station personnel."

The first officer in a written statement reported the following:

"I was the First Officer, flying pilot, on flight 598 (PHX-MCI) on the night of August 24, 2001. We were vectored to the ILS for runway 27, and on final approach experienced light to moderate rain. Upon touchdown, the aircraft gently began to shift to the left edge of the runway and ultimately partially exited the runway into the field, despite using right aileron and rudder inputs. Once stopped, we contacted the tower and asked for emergency vehicles, and then notified the Company. Passengers were de-planed by emergency crews and aircraft control handed off to MCI station personnel."

One of the flight attendants reported the following in a written statement:

"As we were approaching the runway in Kansas City the first flight attendant and I noticed it was raining pretty hard outside, but other than that everything seemed normal. Once we touched down I felt a few bumps and then the plane seemed to skid. At that point I felt a huge bump and a few seconds later we came to a stop. The first [flight attendant] called the flight deck after waiting a few seconds. As soon as she called the flight deck one of the pilots came over the PA and said, 'Remain seated. Situation under control.' The passengers were the first ones to mention we might be off the runway. While I was talking to the passengers from my jump seat the first flight attendant was busy talking to the pilots. The emergency crew at Kansas City arrived on the scene in less than a minute. With the help of the America West personnel in MCI and the emergency crew, the passengers deplaned out of door 1R, down portable stairs and on to waiting buses that took them to the terminal."

PERSONNEL INFORMATION

The captain held an airline transport pilot certificate with airplane single engine and multi-engine land ratings. He held a First Class Medical Certificate that was issued on April 17, 2001. He had a total of about 9,425 flight hours. He had flown 172 hours in the last 90 days and 33 hours in the last 30 days.

The first officer held an airline transport pilot certificate with airplane single engine and multi-engine land ratings. He held a First Class Medical Certificate that was issued on December 12, 2000. He had a total of about 11,740 flight hours. He had flown 238 hours in the last 90 days and 51 hours in the last 30 days.

AIRCRAFT INFORMATION

The airplane was a Boeing 737-3G7, serial number 24633. The CFM 56-3B2 engines delivered 22,000 pounds of thrust each. The airplane's last maintenance inspection was a continuous airworthiness inspection conducted on August 22, 2001. The airplane had flown 26 hours since the last inspection, and had a total time of 37,878 hours.

The airplane had a maximum gross weight of 138,500 lbs. An AWA engineer reported that based on an estimated landing weight of 95,071 lbs. and a landing index of 56.7, the %MAC [mean aerodynamic chord] was approximately 17.4%. This information was predicted upon the planned trip fuel burn of 13,100 lbs.

METEOROLOGICAL INFORMATION

At 0031 cst, the Automatic Terminal Information Service (ATIS) information Quebec was: winds 040 degrees at 5 knots, 7 miles visibility, thunderstorm and light rain, few clouds at 2,000 feet, ceiling 6,000 broken cumulonimbus, 9,000 feet overcast, temperature 23 degrees [Celsius], dew point 22 degrees [Celsius]., altimeter 29.87. Remarks: Frequent lightning in clouds, clouds to ground all quadrants, thunderstorm overhead moving northeast. Runway use program in effect. Arrivals expect visual approach runway 19L.

At 0054 cst, ATC issued the flightcrew a weather update, which was: "few clouds at 1,200 feet, ceiling 6,000 feet broken, 8,500 feet overcast, visibility 10 miles light rain. Wind three six zero at eight, altimeter 29.88." The controller subsequently issued the flightcrew windshear alerts of 20 knots within 2 miles of the airport and heavy rain at the airport.

At 0113 cst, the special weather observation at MCI was: winds 030 at 4 knots, 1 mile ...