N8PK

HISTORY OF FLIGHT

On September 5, 2001, at 1313 eastern daylight time, a Piper PA-31-350, N8PK, operated by Panda Air, Limited, Ferndale, New York, was destroyed when it impacted terrain in Bern Township, Pennsylvania. The airplane was returning for landing, shortly after takeoff from Reading Regional/Carl A. Spaatz Field (RDG), Reading, Pennsylvania. The certificated airline transport pilot was fatally injured. Visual meteorological conditions prevailed, and no flight plan had been filed for the flight to Orange County Airport (MGJ), Montgomery, New York. The positioning flight was conducted under 14 CFR Part 91.

The Reading Air Traffic Control Tower was operating a combined ground/local controller position. At 1301, the pilot called for ground taxi, and was advised to taxi to runway 36. At 1310, the pilot called "ready to go three six, be a right turnout." He was then cleared to take off from runway 36, and make a right turnout on course. At 1312, while a ground vehicle was talking to the tower controller on the ground frequency, the pilot called the tower on the local frequency and stated "...tower, i gotta return, i got an engine problem eight papa kilo."

About 10 seconds after the pilot's initial call, the tower controller asked him if he required any assistance. When the pilot did not respond, the controller transmitted that he understood the pilot was returning for a landing, and again asked the pilot if he required any assistance. The pilot's response was, "(unintelligible) ah no, no (unintelligible)." At 1313, the controller told the pilot to fly left traffic for runway 36. He also gave the pilot the current weather, and stated that runway 31 was available. There were no further communications from the pilot.

In a subsequent radio transmission to a ground vehicle, the tower controller stated that the airplane had disappeared behind a hill in a vertical descent.

According to one witness, a former air crash/rescue airport employee and current police officer, he was in his house about 1/4 mile from the departure end of runway 36, when he heard the airplane fly overhead. One of the engines sounded "strange", as if it was not making full power. The witness went outside, and saw that the airplane was about 200 feet in the air, and puffs of white smoke were coming from the rear of the left engine. The engine, however, was still operating, and did not sound like it was "missing". The airplane then turned to the left, toward the northwest, and eventually began a left bank as if to land on runway 13. It then entered a "snap roll real hard to the right" followed by a nose-dive, and disappeared below a tree line. The next thing the witness saw, was a plume of black smoke rise from the area. The witness remembered thinking that if the left engine had lost power, he would have expected the airplane to roll to the left. He could not understand why it rolled to the right.

Another witness was in his car and stopped at a traffic light, heading northwest, just northwest of Reading Airport. He saw the airplane come into view from his right, and move to his left while climbing. The witness estimated that the airplane was about 1,000 feet in the air and was "really moving, like it was under full power." The airplane then flew over a tree line, banked hard to the left, "like going into a left hand wingover," and entered a sharp dive towards the ground. The dive was not straight down, but the airplane was "very nose down." The witness lost sight of the airplane as it went below the tree line, but shortly thereafter, he saw a huge round ball of smoke rise from the area.

A third witness reported that he was standing in an athletic complex, about five football fields away from the accident site, when the accident occurred. The airplane was between the witness and the airport. The witness stated that his attention was drawn to the airplane because he was used to the sounds of other airplanes and this one just didn't sound right. The airplane didn't have the regular hum of a normal airplane; "it sounded like a giant saw in a saw mill." It was louder than normal, and "not in rhythm." It sounded like "a 'putt-putt-putt;' like it was running out of gas." The witness saw smoke coming out of the airplane. He originally thought the airplane was single-engine, because when he first saw it, it was in an angle of bank, and he could not see two engines. Then he saw it make a "real quick" nose-dive, and lost sight of it as it went below a tree line. The witness was sure that the pilot had no control of the airplane when it suddenly dropped.

A fourth witness was an engine mechanic who heard, but did not see the accident. He stated that he heard one engine running smoothly, and the other engine "popped." It sounded like a "lean pop," like an automobile engine not getting enough gas; it did not sound like an ignition problem.

According to smoothed radar tracking data, the airplane turned toward a left downwind, and leveled off at 1,400 feet msl (about 1,050 feet agl) and 156 knots. During the next 14 seconds, the airplane descended to 1,100 feet and increased airspeed to 173 knots. Then radar contact was lost.

The accident occurred during the hours of daylight, and in the vicinity of 40 degrees, 22.84 minutes north latitude, 75 degrees, 59.87 minutes west longitude.

PERSONNEL INFORMATION

The pilot held an airline transport pilot certificate, with ratings for single engine and multi-engine airplanes. He was also a certificated flight instructor in single and multi-engine airplanes, and instrument-airplane. His latest Federal Aviation Administration (FAA) second class medical certificate was dated December 15, 2000.

On his medical certificate application, the pilot did not list any visits to health professionals within the previous 3 years. He also did not report being diagnosed with any illnesses, "ever" or "presently". The aviation medical examiner was not the pilot's personal physician.

The pilot's personal physician reported that the pilot had last visited him on May 9, 2001, for "evaluation of inguinal hernia and prostate check.... Prostate was enlarged somewhat, without modularity." The physician indicated that a PSA test was ordered but the results were never received. The physician also noted that the pilot did not present any condition that would have resulted in headaches, dizziness, unconsciousness, heart or vascular problems, neurological disorders, depression, or any other afflictions that might have led to incapacitation. The physician did not know if the pilot had been seeing another health care professional.

The president of Panda Air had been in contact with the pilot on and off for about 15 years. The pilot had previously sought employment with his company, but until recently, the timing had not worked out. The pilot was engaged to be married, and had a young child and two older children. The pilot did not appear to be financially well off, and supplemented his flying income with work as a carpenter.

The pilot's logbook was not recovered. On his resume provided to Panda Air, he stated that he had 3,210 hours of flight time, including 1,385 hours in multi-engine airplanes and 1,150 hours as a flight instructor. According to company records, he began flying the PA-31-350 on July 30, 2001, and completed 7 flights with 20.2 hours' duration prior to the accident flight. Company personnel also stated that the week before the accident flight, the pilot had practiced numerous simulated engine-out scenarios. He had also been deemed proficient by the company's training captain to begin flying solo 14 CFR Part 91 flights, in preparation for a 14 CFR Part 135 checkride. The flight to Reading was his first solo flight in the airplane.

The company's training captain described the accident pilot as "smooth, conscientious and capable." In addition:

"At no time did I observe the control or safe operation of the aircraft to be in doubt. [The accident pilot] was familiar with the POH of this aircraft and was fluent in the emergency procedures. He had a calm presence in the cockpit and was also a person of humor and wit."

The training captain also noted that the accident pilot was a freelance writer, and "had recently published a work on cancer cure research (as he related to me.)" The accident pilot had also been looking forward to being with his fiancee and child during an upcoming vacation. "He seemed to have a love for life and a developed spiritual dimension as well."

AIRCRAFT INFORMATION

The Piper PA-31-350 was equipped with Lycoming TIO-540 and LTIO-540 counter-rotating engines. A vortex generator (VG) kit was also installed.

Prior to the accident flight, the airplane was at Aerodynamics of Reading, Incorporated, for maintenance. Aerodynamics operated two PA-31-350's of its own, and maintained three more for companies other than Panda Air.

According to work orders, 50-hour and 100-hour maintenance inspections were completed on August 24, 2001. A maintenance technician noted that, among the maintenance items addressed, personnel at Panda Air had reported that the right engine had a higher oil consumption than normal, but that the oil consumption of the left engine was "very low and of no concern." Oil leaks from the right engine's #1, #2, and #4 cylinder pushrod tubes were corrected, and subsequent engine runs confirmed a lack of oil leakage from either engine.

The airplane returned for additional maintenance on September 4, 2001, which included the adjustment of the left engine manifold air pressure, the alignment of both engines' breather tubes, the fabrication and installation of a new fuel drain tube for the left engine, the removal and replacement of the left elevator to install rivets at the inboard hinge, and the removal and replacement of the right elevator to dress an area where a bolt had ...