N777AJ

HISTORY OF FLIGHT

On February 2, 2007, about 0930 central standard time, a Raytheon Aircraft Company B200, N777AJ, was substantially damaged due to acceleration forces incurred during an uncontrolled descent and recovery from cruise at flight level (FL) 270. Visual meteorological conditions prevailed at the time of the accident. The flight crew reported they depressurized the airplane after a cracked/shattered windshield. They then donned their oxygen masks but were unable to obtain oxygen from the oxygen system resulting in their loss of consciousness. They later regained consciousness, recovered from the descent, and landed without further incident at Cape Girardeau Regional Airport, Cape Girardeau, Missouri. The 14 CFR Part 91 business flight was operating on an instrument flight rules plan. The pilot and copilot were uninjured. The flight originated from Rogers Municipal Airport-Carter Field (ROG), Rogers, Arkansas, at 0839.

The business flight was a positioning flight with no passengers aboard. The pilot had the copilot accompany him on the positioning flight so that the copilot could accumulate flight time. The copilot was not a company pilot and had not attended or completed an initial/recurrent training course for the airplane or received a checkout in the airplane.

The pilot stated that he checked the oxygen system during his preflight checks but turned the system off for the accident flight because he wanted to "save" the oxygen within the oxygen system. He stated he didn't want the oxygen to deplete if the system were left on. He also stated that the windshield heater was in the OFF position and was not turned ON after departing from ROG.

The pilot stated in a National Transportation Safety Board (NTSB) Pilot/Operator Report, that the left pilot windshield "shattered" but stayed in place. He stated that "within seconds," he began to depressurize the airplane because the integrity of the windshield was unknown. He instructed the copilot to don the oxygen mask. The pilot pulled the left oxygen handle and "it did not seem to engage properly." He then pulled the right oxygen handle and the oxygen masks deployed in the rear cabin. The oxygen still did not "seem" to be delivering to the crew masks because he had tunnel vision and was having trouble thinking clearly. The last thing he remembered was being in an emergency descent. He disengaged the autopilot and pitched down, but was not able to reduce power to idle or extend the landing gear.

The pilot was interviewed a second time following the readout of the cockpit voice recorder (CVR). During the interview, the pilot stated that he was out of the pilot seat but had his leg on it while twisting around to empty trash.

The NTSB Vehicle Recorders Laboratory read out the airplane CVR and transcribed the recording as follows:

0854:01, Memphis Center clears aircraft to FL 270

0857:06, the pilot makes comment about setting the pressurization. Climbing you look at the inner scale and descending you look at the outer scale

0905:42, the pilot leaves the cockpit to "fetch the trash can"

0905:56, comment heard only on the cockpit area microphone channel (CAM) from the pilot saying "don't tear it up while I'm gone"

0909:01, a sound of a very loud snap was heard on all CVR channels

0909:03, the copilot exclaims the pilot's first name.

0909:08, comment heard only on CAM channel from the pilot saying "what'd you # break"

0909:16, comment heard only on CAM channel from the pilot saying "gunna dump the cabin"

0909:38, the copilot exclaims "what the #"

0909:42, the copilot states, "we need to go on oxygen"

0909:43, the pilot says "yeah"

0910:06, Center instructs the airplane to change to Memphis Center frequency but the airplane never changes frequency and remains on Memphis Center for the remainder of the CVR recording

0910:12, loud right seat pilot breathing starts and continues to the end of the recording

0910:25, comment heard only on CAM channel from left seat pilot saying "can't get no oxygen"

0910:36, comment heard only on CAM channel from left seat pilot saying "I ain't getting no oxygen"

0910:46, comment heard only on CAM channel from the pilot saying, "you got oxygen" (last comment heard on CVR recording from either pilot). After this time the only crew noise was the sound of the copilot breathing erratically.

0914:55, change in background engine propeller noise starts and continues until the end of recording

0915:20, start of 500 hertz (Hz) beeping tone that continues until end of recording (landing gear warning horn)

0916:41, start of alternating high (1 Khz) low (500 Hz) tones beeping at 5 Hz rate and continues until end of recording (over speed warning horn)

0916:57, sound of one altitude alert tone

0917:05, alternating high low tone transition to steady (1 Khz) tone began and continued for approximately 4 seconds

0917:17, sound of one altitude alert tone

0917:23, alternating high low tone transition to steady (1 Khz) tone continued for approximately 6 seconds

0917:54, sound of increasing wind noise

0918:28, the recording stopped while the airplane was still airborne

PERSONNEL INFORMATION

Pilot

The pilot held an airline transport pilot certificate with a multiengine airplane land and a commercial pilot certificate with an airplane single-engine landing rating.

The pilot completed a flight review during B200 training at Simcom International on August 24, 2006. At the time of the accident, he accumulated a total aircraft time of 4,048 hours of which 110 hours were in B200 airplanes.

According to Federal Aviation Administration (FAA) records, the pilot was involved in an incident on Oct 24, 2006, while flying N777AJ inbound to Adams Field Airport, Little Rock, Arkansas, in order to have scheduled maintenance performed on N777AJ. During the approach/landing, the pilot was unaware that the landing gear was not extended until queried by local air traffic control to check the airplane landing gear because it was not extended. The pilot then departed the airport traffic pattern and reportedly reset the circuit breaker and then landed without further incident. Post incident maintenance inspection of the airplane did not reveal any mechanical anomalies that would have precluded normal operation of the landing gear system.

Copilot

The copilot held a commercial pilot certificate with airplane single-engine land, airplane multiengine land and instrument airplane ratings. He also held a certified flight instructor certificate with single-engine land, multiengine land, and instrument airplane ratings.

At the time of the accident, he accumulated a total aircraft time of 2,806 hours of which 28 hours were in B200 airplanes.

AIRCRAFT INFORMATION

The airplane was a 1998 Raytheon Aircraft Company B200, serial number BB-1638, which accumulated a total time in service of 1,834.8 hours at the time of the accident. The airplane was last inspected during phase 1 to 4 inspections, which were completed on August 29, 2006.

The pilot windshield, model number 101-384025-21, serial number 98264H7442 was installed at the time of the airplane manufacture and subsequently had not been overhauled or repaired prior to the accident. The windshield had accumulated 1,834 hours of service and had no previous reports of delamination or cracking.

The crew and cabin oxygen system controls are located on the cockpit control pedestal via left and right push-pull control handles. Actuation of the left push-pull control handle actuates the oxygen system shutoff valve and places the oxygen system in ready mode. The right push-pull control handle is the passenger manual override control that will manually deploy the passenger oxygen masks. Oxygen will flow to each passenger mask only if the oxygen tank shutoff valve is in an OPEN position.

METEOROLOGICAL INFORMATION

The Springfield, Missouri, upper air temperature recording for FL 270 at 0600 was -39 degrees Celsius.

FLIGHT RECORDERS

The CVR was mounted aft the rear pressure bulkhead at waterline 124.00 and fuselage station 368.75. The CVR incorporated a 4-g impact switch, which was found deactivated (in the open position) at the time of the on-scene examination. The impact switch deactivates the CVR at 4-g.

WRECKAGE AND IMPACT INFORMATION

On-scene inspection of the airplane noted that approximately 2/3 of the left horizontal stabilizer and elevator were separated from the airplane and 2/3 of the right elevator was separated but attached at the inboard hinge. The left and right wings were wrinkled. The left pilot windshield outer and inner plies were intact. The inner ply exhibited a shattered appearance with a crack at the lower right hand corner of the windshield.

The cabin pressurization dump switch was in the dump position.

The left and right push-pull pedestal control handles were in the pushed in position.

The passenger oxygen masks were deployed.

TESTS AND RESEARCH

A plot of recorded radar data shows at 1517:45 the airplane was at an altitude of 25,400 feet and at 1522:59 the airplane was at an altitude of 7,800 feet. There were no radar data points between this time.

The oxygen system worked when it was functionally tested after the accident in accordance with the Super King Air B200/B200C Airplane Flight Manual (AFM).

The AFM Before Engine Starting checklist items requires that the oxygen system ready switch to be selected to the ON position and the oxygen system is to be checked. The Abnormal Procedures section for a Cracked or Shattered Windshield is:

1. Altitude - MAINTAIN 25,000 ft OR LESS, IF POSSIBLE

2. Pressurization Controller - RESET

a. Cruise and Descent - MAINTAIN A CABIN DIFFERENTIAL PRESSURE OF 2.0 TO 4.6 PSI

b. Before Landing - DEPRESURIZE CABIN PRIOR TO TOUCHDOWN

3. Other In-flight Considerations

a. Visibility through a shattered windshield may be sufficiently reduced to dictate flying the airplane from the opposite side of the cockpit.

b. Precautions should be taken to...