N2731P

On August 9, 2007, at 0707 eastern daylight time, a Piper PA-22-160, N2731P, registered to and operated by a private owner as a 14 CFR Part 91 personal flight made a forced landing to an open field on initial take off climb. Visual meteorological conditions prevailed and no flight plan was filed. A post crash fire destroyed the airplane. The private pilot and one passenger reported minor injuries. The remaining passenger was transported to a local area hospital with serious injuries and died at 2115. The flight originated from ST. Mary's County Regional Airport, Leonardtown, Maryland, on August 9, 2007, at 0706.

The pilot informed the Maryland State Police at the accident site that he was concerned about the weight of the airplane and the possible performance due to the hot weather. The pilot stated the airplane was slow to accelerate on the take off roll, which the pilot attributed to the hot and humid weather. The pilot stated the airplane became airborne 3,000 feet down the runway and his initial rate of climb was about 50 feet per minute well below normal. As the airplane approached the tree line located about 1,500 feet from the end of the runway, the airplane was not climbing and had started to descend. The pilot deployed 25-degrees of flaps allowing the airplane to clear the trees. The airplane continued to descend into a field located about 1,000 feet beyond the tree line. The airplane collided with the ground and collapsed the landing gear, slid about 66 feet, turned 90-degrees to the right and stopped. The airplane caught on fire and they exited the airplane.

The pilot stated in a telephone interview with the NTSB after the accident that the airplane was topped off with 17 gallons of 100 low lead fuel before departing. No formal performance planning was conducted except for mentally going over the weight and balance in his head. The maximum gross weight of the airplane was 2,000 pounds and he estimated his take off weight at 1,814 pounds. The pilot stated he considered the density altitude and pressure altitude but did not consider it a factor with the 4,000-foot departure airport. The pilot stated the airplane has a tendency to sit tail low due to the nose landing gear strut being extended for landings at his private airstrip. He started his take off roll from runway 29 and the ground roll was slower than normal down the 4,000-foot long runway. The pilot pushed the control wheel down in an effort to increase airspeed. The airplane was about 3,000 feet down the runway when he rotated the airplane at 80 mph. The airplane came off the runway; the airplane had a reduced rate of climb, and was basically flat. The airplane was at full power and the pilot was concerned about clearing the trees off the departure end of the runway and lowered one notch of flaps. Just before reaching the tree line, the pilot lowered the flaps to the full down position and the airplane skimmed the top of the tree. The airplane would not maintain altitude and was descending. The airplane touched down in an open field in a nose down right wing low attitude in an attempt to follow the contour of the open field. The nose wheel was either bent aft or separated. The airplane began sliding to the right and turned about 90-degrees before it came to a complete stop and caught fire. When the pilot was asked if the airplane had any mechanical problems on takeoff, the pilot replied no. "It was my fault, I made a bad choice, the airplane was heavy, it was hot, and very humid." When asked why he did not abort the take off the pilot stated, "I never thought about it and I do not know why. I just kept the nose on the runway. I knew we were heavy and it was hot." The initial statement was read back to the pilot and the pilot agreed with the initial statement.

A witness who is also a commercial pilot and a flight instructor observed the accident airplane taxi from the gas pump towards runway 29 for take off. As the airplane taxied by his location, the witness observed the tail of the airplane was low "as if the airplane was overloaded." The airplane started its take off roll and the winds were light and variable with a high-density altitude. The witness stated the runway at the airport is 4,150 feet long. The accident airplane takeoff roll was slow and long and there was no change in engine noise on the takeoff roll or climb out. The airplane used about 3,000 feet of the runway before the pilot "forced the airplane off the runway." Once the airplane became airborne the climb out was "flat" and the witness was not sure if the airplane would clear the trees off the departure end of the runway. The airplane cleared the trees by about 100 feet and disappeared from view behind another tree line. The witness stated he observed a plum of black smoke and knew the airplane had crashed.

PERSONNEL INFORMATION

Review of information on file with the FAA Airman's Certification Division, Oklahoma City, Oklahoma, revealed the pilot was issued a private pilot certificate on March 26, 2004, with ratings for airplane single engine land. The pilot holds a third-class medical certificate issued on March 21, 2007, with the restrictions, "must have available glasses for near vision, and not valid for night flying." The pilot indicated on the application for the third-class medical certificate that he had accumulated 600 total flight hours. The pilot's last biennial flight review was completed during the summer of 2006.

AIRCRAFT INFORMATION

The post-crash fire destroyed the airplane logbooks. According to the pilot the airplane had about 1.958 total airframe hours, and the engine had about 600 total hours since major overhaul. The tachometer was destroyed and the exact total time on the airframe and engine could not be determined. The pilot stated the last annual inspection was conducted in January or February 2007, and the airplane had flown about 20 hours since the annual inspection.

Review of delivery documents obtained from the aircraft manufacturer revealed the accident airplane; serial number 22-3037 is a PA-22-150, and the empty weight is 1,135 pounds. The pilot stated the airplane is a PA-22-160 and the empty weight is 1,050 pounds. The maximum gross weight of the airplane is 2,000 pounds. The pilot estimated his weight at 240 pounds and the estimated weight for his son and his mother was 140 pounds each. In addition he informed the FAA in a statement that the airplane had less than 100 pounds of baggage, which was located in the right rear-facing seat. In addition, the pilot informed the FAA that10 pounds of tools were located in a storage compartment. The pilot informed the NTSB that he had 65 pounds of baggage in the right rear seat.

With an empty weight of 1050 pounds, 520 pound for the pilot and two passengers, 75 pounds of baggage and tools, and 216 pounds of fuel, the airplanes take off weight would be 1,861 pounds. With 100 pounds of baggage and 10 pounds of tools the takeoff weight would be 1,896 pounds.

With an empty weight of 1,135 pounds, 520 pounds for the pilot and two passengers, 75 pounds of baggage and tools, and 216 pounds of fuel the airplanes take off weight would be 1,946 pounds. With 100 pounds of baggage and 10 pounds of tools the takeoff weight would be 1,981 pounds.

AIRPORT INFORMATION

The St. Mary's County Regional Airport, Leonardtown, Maryland, is located at an elevation of 142 feet. Runway 11 and runway 29 surface is asphalt and in good condition. Both runways are 4,150 feet in length and 75 feet wide. The airport has an Aviation Weather Observation Service (AWOS) available on frequency 119.575.

METEOROLOGICAL INFORMATION

The St Mary's County Regional Airport, Leonardtown, Maryland, 0701 surface weather observation was wind calm, visibility 10 miles, clear, temperature 82-degrees Fahrenheit, dew point temperature 72-degrees Fahrenheit, and altimeter 29.88 The density altitude at the time of the accident was 1,755 feet and the pressure altitude was 180 feet.

WRECKAGE AND IMPACT INFORMATION

The airplane wreckage was located in an open field on private property in the vicinity of 23595 Lawrence Hayden Road, Leonardtown, Maryland. Examination of the crash site revealed the airplane had collided with the ground on a heading 290-degrees, and a post crash fire consumed the majority of the airplane.

Examination of the nose section revealed the engine assembly was fire damaged and displaced to the right. The nose wheel was bent aft and remained attached to the engine mount at the firewall. The upper and lower engine cowling was fire damaged. The propeller spinner remained attached to the propeller hub and was bent inward. The propeller assembly remained attached to the propeller crankshaft flange. One propeller blade was bent aft at mid span and the remaining propeller blade was not damaged.

The cabin area was consumed by fire from the engine compartment attending rearward to the empennage except for the steel tubes welded together to form the rigid structure. The instrument panel, flight instruments, radios, master switch, starter button, circuit breakers, panel lights, landing light switch, parking brake, and the front seats and rear seat were destroyed. An eight-gallon reserve fuel tank was not installed. The throttle, mixture, and fuel selector valve were destroyed by the post crash fire. The flap handle was in the extended position. The aircraft registration and airworthiness certificate was consumed by fire. The left main landing gear remained attached, and the right main landing gear was separated. Continuity of the flight controls assembly was confirmed from both control yokes rearward to the flight control surfaces.

The right wing was fire damaged, bent aft, and separated from the fuselage at the wing hinge fittings and lift strut. The right lift strut was fire damage. The right main fuel tank was ruptured and fire damaged. The right aileron and flap remained attached at their attachment point and were fire ...