N141LG

HISTORY OF FLIGHT

On December 3, 2007, about 1718 Alaska standard time, a Eurocopter BK117C1 helicopter, N141LG, is presumed to have sustained substantial damage during impact with ocean waters, about 3 miles east of Whittier, Alaska. The helicopter was operated by Evergreen Alaska Helicopters, Inc., under contract to Providence Hospital, Anchorage, Alaska, under their Lifeguard Program, as a visual flight rules (VFR) patient transport flight under 14 CFR Part 135. Of the four persons aboard, the commercial pilot, paramedic, nurse, and patient, only the body of the nurse was recovered. The remaining three were not located, and are presumed to have also died. Instrument meteorological conditions prevailed in the area of the accident, and company VFR flight following procedures were in effect. The accident flight departed Cordova, Alaska, about 1640.

The helicopter was based in Soldotna, Alaska, and flew to Cordova to pickup the patient about 1340. After boarding the patient, the helicopter departed for Anchorage about 1640. During the flight from Cordova to Anchorage, the pilot communicated with the hospital's communications center at 10-minute intervals via satellite telephone. During the communications he gave the helicopter's position and estimated time of arrival in Anchorage. The helicopter was reported missing when the pilot failed to make a required position report, and attempts to communicate with him failed.

On the evening of December 3, the Alaska Rescue Coordination Center (ARCC) initiated a search for the missing helicopter. Initially, search efforts were restricted to watercraft due to weather in the search area. The following day both aircraft and watercraft carried on the search, as well as ground searchers on land. On December 8, the body of the nurse and some wreckage were found floating in Passage Canal near Whittier. On December 10, the active search for the helicopter and its three missing occupants was terminated.

The flight from Cordova to Anchorage required flying over/near the ocean waters of Prince William Sound. Prince William Sound is an isolated area with no roads, few small towns/villages, and essentially no land or water-based lights. For patient transfers from Cordova to Anchorage, Providence hospital routinely used airplanes operating under instrument flight rules as the preferred transportation method. The use of the helicopter was the last option. Helicopter flights operate under visual flight rules only.

The VFR flight in a helicopter from Cordova to Anchorage typically would follow the north and east boundary of Prince William Sound to avoid extended flight over water.

The accident flight departed Cordova about 1640, and official sunset was 1548. Federal Air Regulation Part 135.205(a) states: No person may operate a helicopter under VFR unless that person has visual surface reference, or at night, visual surface light reference, sufficient to safely control the helicopter.

DAMAGE TO AIRCRAFT

To date, the only pieces of helicopter wreckage recovered are fragmented pieces of the main rotor blades, and the aft left cabin door. Two flight helmets belonging to the flight nurse and the pilot were found floating in the surf. Night vision goggles were attached to the helmets via lanyards. The NVG switches were found in the "ON" position.

PERSONNEL INFORMATION

No personal flight records for the pilot were discovered for examination, and the following information was taken from operator and FAA records.

The pilot held a commercial pilot's certificate, with ratings for airplane single-engine land, helicopter, and instrument helicopter. An FAA second class medical certificate was issued to the pilot on January 29, 2007, with the limitation that he must wear corrective lenses. The pilot was hired by Evergreen Helicopters on April 16, 2007. At the time of the accident he had about 2,678 hours of flying experience. Of those hours, about 2,398 were in helicopters, and about 120 hours were in the same make and model as the accident helicopter. The pilot had 65 hours of night flying experience, 78 hours of simulated instrument flight, and 18 hours of actual instrument flight time. He accumulated about 70 hours of Alaska time working for another operator during the summer in Southeast Alaska, and 109 hours with the current operator for a total of 179 hours of Alaska time. He had not previously flown during the winter months in Alaska.

For night vision goggle (NVG) training he had flown three flights for 5.0 hours total flight time. The flights included inadvertent IMC procedures, and unusual attitude recovery. The NVG training was begun on August 20, and completed on August 22, 2007. According to the FAA, the pilot did not complete the NVG training as prescribed by the vendor/trainer, which according to the trainer, required five separate flights for a total of at least 5 hours of flight time, and therefore the pilot was not qualified to use NVG. The FAA had not assigned a Principal Operations Inspector (POI) to the operator at the time of the NVG training, and did not cancel the pilot's NVG usage, as the discrepancy was not discovered until after the accident. According to the operator, they understood that the pilot required 5 hours of NVG flight, not specifically five flights, and therefore they believed the pilot was trained to qualification.

Route training was provided to the pilot during his local area familiarization flights, however Cordova was not included in that familiarization training. No evidence was discovered showing that the pilot had ever flown to or from Cordova.

The pilot completed and passed a Federal Air Regulation Part 135.293/299 Airman Competency Check ride on May 8, 2007, given by a company check airman. The check ride included instrument navigation and communications procedures, use of the auto pilot, inadvertent IMC procedures, and unusual attitude recovery. The accident pilot held an instrument rotorcraft certificate, but was not required to be IFR current.

According to the check pilot, the accident pilot was a capable pilot, and current in all of his required pilot tasks and training.

The pilot's weather training consisted of completing the operator's interactive computer module, which was completed on May 5, 2007.

The operator's pilot training manual contains a section titled, "Special Subjects Training - For Additional Pilot Authorizations." Additional training subjects include underwater evacuation and ditching; however, the training was not required for the EMS helicopter position and was not provided to the accident pilot or crew.

The medical flight crews received formal training from the operator, in the operation of some helicopter systems, principally communications, patient care relative to flight, airspace surveillance, NVG usage, and emergency procedures. Essentially, medical flight crewmembers who had flown with the accident pilot, felt he was conscientious, professional, and a good pilot. One crewmember said on one occasion, he and the pilot got into severe turbulence, and after the flight the pilot was visibly shaken, as was he. Another crewmember said he was concerned about the number of days in a row the pilots worked 12 hour shifts, and wrote a letter to his supervisor because he was concerned that the accident pilot was making mistakes due to fatigue. The letter was forwarded to the operator, and the pilots were give additional days off.

OPERATOR INFORMATION

Evergreen International is a multinational aviation company supporting hundreds of aircraft worldwide. At the time of the accident, Evergreen Alaska Helicopters, Inc., a subsidiary of Evergreen International, supported numerous helicopter operations throughout Alaska, including two dedicated EMS helicopters, both of which were contracted to Lifeguard, Providence Hospital.

The accident helicopter was stationed at Providence Hospital, Soldotna, Alaska, and designated for day/night VFR operations only.

At the time of the accident, operational control of flight operations was specified in the company's FAA-approved Operations Specifications. The specifications stated in part, "...operational control is named management personnel to include Chief Pilot, Director of Maintenance, Chief Inspector, and Director of Operations." Under paragraph 7(a), the operations specification stated in part, "...prior to the certificate holder conducting any flight operation under Part 135, the certificate holder must provide information to the designated pilot in command that indicates which flight or series of flights will be conducted under Part 135, that indicates which Part 91 flights will be conducted by the certificate holder, and that the certificate holder is accountable and responsible for the safe operations of these flights or series of flights." According to the operator, all flights for Providence Hospital were conducted under Part 135.

According to the company operations manual Chapter 10, page 4, Pilot in Command: "The Director of Operations and the Pilot in Command are jointly responsible for the initiating, continuation, diversion, and termination of a flight in compliance with Regulations and Evergreen's Operations Specifications."

The crew for the helicopter at Soldotna was a single pilot, and usually two medical crewmembers. The pilot has numerous tools to conduct flight operations, including computer access to weather data, and company operations specifications and procedures.

Pilots received an annual Part 135 check ride, and annual safety training. The company did make a helicopter and fuel available for pilots who wanted to stay instrument current. The instrument training/currency was voluntary. No evidence was presented showing that the accident pilot was instrument current.

At the time of the accident, the company operations manual stated that when inadvertent IFR was encountered, the pilot’s primary responsibility was to maintain attitude control ...