N2YT

HISTORY OF FLIGHT

On June 26, 2009, about 1644 eastern daylight time, an experimental amateur-built Glasair III, N2YT, was substantially damaged when it impacted trees and terrain about 1 minute after takeoff from Manassas Regional Airport (HEF), Manassas, Virginia. The certificated private pilot/owner and the passenger were seriously injured. The personal flight, destined for Warrenton-Fauquier Airport (HWY), Warrenton, Virginia, was operated under the provisions of Title 14 Code of Federal Regulations Part 91. Visual meteorological conditions prevailed, and a Washington DC "Special Flight Rules Area" (SFRA) flight plan was filed for the flight.

According to the pilot, the airplane was hangared at HEF. The airplane's most recent annual inspection was completed a few weeks prior to the accident, and it had been flown successfully several times since then. The airplane was last fueled by a fuel provider at HEF 4 days prior to the accident. Both tanks in the airplane were topped off, and fuel records indicated that a total of 28.9 gallons were uploaded.

According to Lockheed Martin, the SFRA flight plan was filed to the "FLUKY Gate" of the SFRA, with an en route time of 7 minutes. The flight plan indicated that the airplane had 4 hours of fuel on board at the time of departure. A Lockheed Martin flight briefer provided the pilot with a weather briefing for a flight from HEF to HWY, which was located 12 miles southwest of HEF.

The pilot stated that the purpose of the flight was to bring the airplane to a maintenance facility at HWY, in order to address a landing gear retraction-rate issue. Depending on the outcome of the examination, the pilot planned to either fly or drive back from HWY the same day. The pilot stated that 1 hour elapsed between the time he arrived at HEF and when he boarded the airplane. Prior to the flight, he conducted a "thorough pre-flight inspection" of the airplane, and it "passed" without any problems. The passenger arrived after the preflight was completed, and he did not examine or operate any mechanisms on the airplane.

The pilot taxied to the run-up area, and used his checklist to complete the engine run-up and other pre-takeoff procedures. He stated that "everything looked good," and shortly thereafter he initiated the takeoff roll on runway 16L. According to the passenger, after takeoff, when the airplane was approximately crossing over the end of the runway, he saw fuel venting from the right wing tank filler neck. He stated that the cap was completely displaced from the tank filler neck, and was "flopping around" at the end of its lanyard. He notified the pilot about his observation. The passenger was aware that the airplane had "a lot of fuel on board," and he "was not concerned" about possible fuel exhaustion.

According to the pilot, he "couldn’t believe how the cap had come loose because [he] had checked that the gas caps were secure twice prior to our flight and there had never been any issues with them leaking or becoming loose before." In the pilot's opinion, "fuel was evacuating the plane at an alarming rate."

A review of the recorded air traffic control tower (ATCT) communications revealed that 1 minute and 11 seconds after the takeoff clearance was issued, a communication presumed to be from the accident airplane stated "Manassas tower, my fuel cap is off, emergency landing." About 11 seconds later, the pilot transmitted "Manassas tower, two yankee tango, I'm spilling fuel can I land on three four ri..." Two ATCT controllers saw the airplane start to turn, and then descend "fast" into the trees southeast of the airport. After that, and about 19 seconds after the pilot's first and only call that included the airplane identity, an ATCT controller transmitted a call to the airplane. No subsequent transmissions were received from the airplane.

According to the passenger, the pilot radioed HEF ATCT, but they did not respond immediately. The pilot again radioed the ATCT, and requested an emergency landing in the direction opposite the takeoff direction. Shortly thereafter, the pilot banked the airplane "to the southwest," and then he pulled up and made a "hard bank" to the right. The next thing that the passenger was aware of was the airplane "diving for the trees."

According to some personnel who responded to the accident, the airplane impacted trees and terrain approximately 2,000 feet southeast of the southern end of runway 16L. The tree and ground scars were consistent with a moderately steep descent, oriented along a heading of approximately 170 degrees. Another observer reported that the distance from the first tree strikes to the wreckage was approximately 180 feet, and was oriented on a heading of 130 degrees. There was no postimpact fire. The wreckage was subsequently recovered to a secure facility.

PERSONNEL INFORMATION

Federal Aviation Administration (FAA) records indicated that the pilot was issued a private pilot certificate, with an airplane single-engine land rating, in August 2008. He reported that he had approximately 175 total hours of flying experience, which included 55 hours of dual flight, and 5 hours of solo flight, in the accident airplane. The pilot's flight logbook was not located during the investigation. His most recent FAA third-class medical certificate was issued in August 2006.

AIRCRAFT INFORMATION

The Glasair III airplane was a two-place, low-wing monoplane design that was constructed primarily of composite materials. Glasair III plans, kit components, and raw materials were available from the kit manufacturer, Stoddard-Hamilton Aircraft. The accident airplane was equipped with retractable tricycle-style landing gear, and was powered by a Lycoming IO-540-K six cylinder engine and a two-bladed, constant-speed propeller.

According to FAA records, the airplane airworthiness certificate and initial operating limitations were issued in June 1991. The Phase II operating limitations were issued in September 2004. The accident pilot purchased the airplane in July 2008. According to the airplane maintenance records, the most recent condition inspection was completed on June 9, 2009. The records indicated that the airplane had 363 total hours in service, and the tachometer registered 239.5 hours as of the annual inspection.

A pilot-rated acquaintance of the pilot, who was very familiar with the accident airplane, and who assisted the pilot in learning to fly the airplane, provided additional details regarding the airplane performance and operation. He stated that the pilot owned two different sets of wing tips for the airplane; the "long wing" and "short wing" tips. At the time of the accident, the "long wing" tips were installed. The normal takeoff procedure was to use 10 degrees of flaps, retract the landing gear first, and then retract the flaps. The maximum landing-gear-extended speed was 140 mph, and the maximum flaps-extended speed was 110 mph. The best glide speed for the airplane was 140 mph, which yielded a descent rate of approximately 2,500 feet per minute. The airplane's stall speed was 95 mph with the flaps and landing gear retracted, and approximately 90 mph with 10 degrees of flaps.

The airplane was equipped with an Advanced Flight Systems, Inc. "Pro" model angle of attack ("alpha") indicating system that utilized pressures from two dedicated ports on the wing, plus the airplane’s pitot and static pressures, to determine the angular difference between the relative wind and the zero lift angles. The system presented the information visually to the pilot via a liquid crystal display mounted in the upper center of the left-hand instrument panel. The system was capable of providing an audible warning, and the audible warning could be muted by the pilot. The investigation was not able to locate any warning system calibration data, or otherwise determine the accuracy of the alpha warning system as installed on the airplane. In addition, the investigation was not able to locate any airspeed system calibration data, or otherwise determine the accuracy of the airspeed indicating system as installed on the airplane.

METEOROLOGICAL INFORMATION

The 1655 recorded weather observation at HEF included winds from 220 degrees at 4 knots, few clouds at 7,000 feet, temperature 30 degrees C, dew point 20 degrees C, and an altimeter setting of 29.70 inches of mercury. Visibility was not reported.

COMMUNICATIONS

Copies of the communications between the HEF ATCT and the accident airplane were obtained from the FAA. A review of these recordings and their transcripts revealed that all communications were normal, until just prior to the accident.

AIRPORT INFORMATION

HEF was equipped with two parallel runways whose centerlines were separated by approximately 750 feet. Runway 16L/34R was 5,700 feet long and 100 feet wide. Runway 16R/34L was 3,702 feet long and 100 feet wide. The thresholds of 16R and 16L were abeam one another. The airport elevation was 192 feet above mean sea level, and the ATCT was operating with at least two controllers at the time of the accident.

WRECKAGE AND IMPACT INFORMATION

The fuselage was separated from the wing structure, but remained on top of, and oriented parallel to, the left wing. The forward fuselage was highly fragmented and deformed. The engine remained partially attached to the engine mount and the firewall, and the propeller remained attached to the engine. The empennage and aft fuselage were relatively intact. The left wing and wing carry-through structure was relatively intact from the left wingtip to slightly outboard of the right wing root, and included the cockpit floor, the seat well for the left pilot's seat, and most of the two control sticks and associated linkage. The right wing was highly fragmented. The nose and main landing gear were separated from the airplane.

Four days after the accident, the wreckage was examined in greater detail. Elevator and rudder control continuity we...