N361DS

HISTORY OF FLIGHT

On December 12, 2010, approximately 2200, central standard time, a Diamond DA-40, N361DS, was substantially damaged by impact and postcrash fire in a field near Pearlington, Mississippi. The personal flight was conducted under the provisions of 14 Code of Federal Regulations Part 91 with no flight plan filed. Night visual meteorological conditions prevailed. The private pilot was fatally injured. The flight departed Destin-Fort Walton Beach Airport (DTS), Destin, Florida, at 1924, en route to Stennis International Airport (HSA), Bay St. Louis, Mississippi.

According to Gulfport approach control personnel, at 2021, the pilot was handed off from Mobile approach control to Gulfport approach when the flight was over the shoreline about 40 miles southeast of Gulfport-Biloxi International Airport (GPT). The airplane’s mode C transponder reported an altitude of 4,500 feet mean sea level (msl). At 2022, the pilot checked in with Gulfport approach and reported that the airplane was flying level at 4,500 feet.

At 2052, the pilot reported he had HSA in sight, and he was 10 miles east of the airport. Radar service was then terminated.

At 2053, the Automated Radar Terminal System (ARTS) tagged the airplane mode C at 5,000 msl, 7 miles east of HSA heading westbound. Between 2053 and 2200, ARTS showed the airplane flying around the Bay St. Louis area making multiple circles. There were altitude variations from a high of 8,400 feet msl at 2100 to 700 feet msl at 2138. About 2200, the last mode C target on the airplane was recorded at 2,000 feet msl.

According to a witness located near the accident site, sometime between 2100 and 2200, he heard a single-engine airplane flying overhead. He said that he heard the engine changing pitch, which made him immediately look up. He saw what appeared to be a single-engine airplane doing loops near his house. He stated that he was able to see the silhouette of the airplane and the two white strobes under its wingtips. The engine pitch dropped as it was climbing. About 3 seconds later, he could see its red and green lights on the wing tips, as well as the strobes again as the engine pitch increased. He observed the airplane as it made “a couple more loops.” He was about to call 911 when the airplane appeared to level out and continue flying west-northwest. About 1 minute later, the airplane made a turn toward the north, and the pitch “normalized.” Local hunters found the downed airplane the next day in a wooded area about 5 miles from the witness’s home.

PERSONNEL INFORMATION

The pilot, age 44, held a private pilot certificate with ratings for airplane single-engine land, multi-engine land, and instrument airplane. The pilot was issued his pilots certificate on August 22, 2006.The pilot's most recent Federal Aviation Administration (FAA) medical examination was performed on February 16, 2009, and he was issued a second-class medical certificate with limitations for corrective lenses. The pilot reported 1,650 hours of flight time on his last medical application, and 30 flight hours within the last 6 months of his exam. The pilot’s logbook was located within the airplane and was destroyed by postimpact fire.

AIRCRAFT INFORMATION

The single-engine, four-seat, low-wing, fixed-gear airplane, serial number 40.261, was manufactured in 2003. The airplane was powered by a Lycoming IO-360-M1A, 180-horsepower engine. The airplane’s logbooks were destroyed by postimpact fire. Review of the last work invoice revealed that the last annual inspection was completed on August 20, 2010. At the time, the airframe and engine had 1,015 hours of operation.

METEOROLOGICAL INFORMATION

The 2055 recorded weather observation at HSA, located approximately 6 nautical miles northeast of the accident site, included winds from 270 degrees at 7 knots, clear skies, 10 miles visibility, temperature 33 degrees F, dew point 24 degrees F, and an altimeter setting of 30.12 inches of mercury. Civil twilight occurred at 1754.

WRECKAGE AND IMPACT INFORMATION

The wreckage was located in a wooded area 6 miles southwest from HSA. The wreckage debris path extended from a field at the beginning of a tree line. There was evidence of three landing gear strikes in the grass at the initial impact point. The airplane traveled approximately 75 feet before entering a tree line. The airplane collided with pine trees and traveled approximately 300 feet through the wooded area and came to rest on a heading of 300 degrees magnetic. The vegetation within the wooded area was very dry, and a postcrash fire was evident around the engine and other components of the airplane. The dry vegetation continued to smolder during examination of the wreckage. The wreckage was located at 30°19’ 20.5” north latitude, 089° 32’10.8” west longitude.

The upper and lower engine fiberglass cowlings were fragmented throughout the debris field. The engine assembly was detached from the airframe and located along the debris path. The engine mounts remained attached to the engine. All accessories remained attached to the engine and were impact- and fire-damaged. The stainless steel and fiberglass firewall was buckled and fire-damaged. The nose landing gear was separated from the airframe.

The propeller hub assembly remained attached to the crankshaft flange. The fiberglass spinner was fragmented throughout the debris path. The three-bladed wooden propeller was found splintered at the initial ground scar. Two blades were splintered at the propeller hub, and approximately 12 inches of the third blade remained attached to the hub.

The forward cabin area windscreen was broken, and pieces were located throughout the debris field. The fiberglass forward cabin area was fragmented and fire-damaged. The lower forward spar was broken in half, and fragments were located throughout the debris path. The instrument panel was destroyed, and all switches and instruments were unreadable. Aileron, elevator, and rudder control continuity could not be confirmed, and all flight control push- and pull-tubes were broken and fragmented throughout the debris path. The flap actuator was found retracted, which is consistent with the flaps in the “up” position.

The rear fiberglass cabin area was fragmented throughout the debris field. The rear passenger door was separated from the fuselage.

The right wing was fragmented throughout the debris field. The right two aluminum fuel tanks were located along the debris path and contained residual amounts of fuel. Both fuel tanks were ruptured and buckled. The fuel cap was secure with a tight seal. The right flap was broken and located in the debris field. The right aileron was located along the debris path and was fragmented and broken. The right main landing gear strut was separated from the fuselage attachment point located along the debris field. The right main landing gear wheel and tire was separated from the strut and fire damaged.

The aft fuselage and empennage was fragmented and located at the beginning of the tree line. The vertical stabilizer was fragmented. The rudder was separated from its attachment fittings and broken in half. The right and left horizontal stabilizers were separated from the empennage and were fragmented. The right and left elevators were fragmented and separated from their attachment fittings.

The left wing was fragmented throughout the debris field. The left two aluminum fuel tanks were located along the debris path and contained residual amounts of fuel. Both fuel tanks were ruptured and buckled. The fuel cap was secure with a tight seal. The left flap was fragmented and located in the debris field. The left aileron was fragmented along the debris path. The left main landing gear strut was separated from the fuselage attachment point located along the debris field. The left main landing gear wheel and tire was separated from the strut.

Examination of the engine revealed the engine exhaust tubes were connected to the engine and damaged. The engine muffler assembly was separated from the engine and damaged. The muffler assembly heat shroud was removed, and no carbon deposits were noted inside of the shroud. The muffler was recovered for further examination. Both magnetos were fire-damaged and could not produce spark. All ignition leads and the ignition harness were fire-damaged. The engine-driven fuel pump housing was fire-damaged, and only the pump arm remained attached to the engine. The fuel lines from the engine-driven fuel pump to the throttle body fuel control unit were fire-damaged and did not contain fuel. All oil supply lines were fire-damaged.

All rocker covers were removed, and no damage was present on the valves or valve springs. The starter was separated from the engine and broken. The alternator was broken, and the armature was located along the debris path. The top sparkplugs were removed, and the electrodes exhibited light gray combustion deposits and were worn normally when compared to the Champion Check-A-Plug chart. A lighted borescope was used to examine the bottom plugs, and the electrodes exhibited light gray combustion deposits, and were worn normally when compared to the Check-A-Plug chart. The fuel flow divider was removed and disassembled, and the diaphragm was found intact. Fuel was not present in the fuel flow divider. The oil filter was destroyed and could not be examined. The accessory housing was removed, and the engine was rotated from the crankshaft flange. Compression and suction were obtained on all cylinders. The rocker arms and valves moved on all cylinders except No. 4 when the crankshaft was rotated. Push rods on the No. 4 cylinder were damaged. Continuity of the crankshaft was confirmed to the rear accessory gears. The interiors of all cylinders were examined using a lighted borescope, and no anomalies were noted.

No preaccident mechanical malfunctions or failures were found that would have precluded normal operation of the airplane.

...