N390TH

HISTORY OF FLIGHTOn June 13, 2011, about 0947 central daylight time, a Boeing B-17G "Flying Fortress" airplane, N390TH, experienced an in-flight fire and emergency landing near Oswego, Illinois. One passenger sustained a minor injury. The remaining 3 flight crew members and 3 passengers were not injured. The airplane was substantially damaged as a result of the postimpact fire. The airplane was registered to and operated by The Liberty Foundation under the provisions of 14 Code of Federal Regulations Part 91 as a repositioning flight. Visual meteorological conditions prevailed for the flight, which was not operated on a flight plan. The flight originated from the Aurora Municipal Airport (ARR), Sugar Grove, Illinois at 0938, with an intended destination of the Indianapolis Regional Airport (MQJ).

The airplane had been at ARR for the weekend before the accident flight as a planned stop for education/demonstration flights; however, a fuel leak had interrupted the scheduled flights. A mechanic associated with the Foundation evaluated and repaired the fuel leak the day prior to the accident flight. According to the mechanic, a final inspection of the repair the morning of the accident flight did not reveal any evidence of a continued fuel leak at that time and the airplane was subsequently returned to service.

The flight crew reported that they noticed a faint odor during initial climb after takeoff. While attempting to locate the source of the odor, the pilot noticed a small amount of smoke near the radio room. The flight crew immediately initiated a turn with the intention of returning to ARR. About that time, they received a call from the pilot of the accompanying airplane advising that there was a fire visible on the left wing. The third crew member onboard the B-17 subsequently confirmed a fire behind the no. 2 engine. The pilot took control of the airplane from the co-pilot and setup for an emergency landing to a field off the left side of the airplane. The co-pilot then shut down the no. 2 engine and discharged the fire bottles. The pilot executed an emergency landing to a corn field about 8 miles southeast of ARR. The co-pilot noted that the airplane touched down smoothly on speed about one-third of the way down the field. The ground was firm and the airplane came to a smooth stop.

Emergency crews were hampered by the muddy field conditions, and the fire ultimately consumed portions of the fuselage and the inboard portions of both wings. PERSONNEL INFORMATIONThe pilot held an Airline Transport Pilot certificate with single and multi-engine land airplane ratings. His certificate included type ratings for B-17, B-737, B-757, and B-767 airplanes. He was issued a first class airman medical certificate without limitations on May 17, 2011. He reported a total flight time of 14,178 hours, with 438 hours in B-17 airplanes. His most recent regulatory checkride was completed on April 17, 2011.

The co-pilot held an Airline Transport Pilot certificate with single and multi-engine land airplane ratings. His certificate included type ratings for DC-9, B-757, B-767, and A320 airplanes. He was issued a first class airman medical certificate with a limitation for corrective lenses on March 4, 2011. He reported a total flight time of 15,000 hours, with 6 hours in B-17 airplanes. His most recent regulatory checkride was completed on August 26, 2010. AIRCRAFT INFORMATIONThe accident airplane was a Boeing B-17G "Flying Fortress," serial number 44-85734. It was mid-wing monoplane design, configured with a retractable, tail wheel landing gear. The cockpit and cabin were accessible through a door located on the right side of the fuselage just forward of the horizontal stabilizer, or through a hatch located in the bottom of the fuselage below the cockpit. The airplane was powered by four 1,200 horsepower Wright model R-1820-97 nine-cylinder, radial engines.

Available information indicated that the accident airplane was delivered to the United States Army Air Force in 1945. In 1947, the airplane was included in a lot of aircraft sold for scrap. However, the accident airplane was not scrapped and was subsequently sold to the United Aircraft Corporation/Pratt & Whitney Aircraft Division for use as an engine development test bed. In 1967, the airplane was donated to the Connecticut Aviation Historical Association. Unfortunately, in 1979, the airplane was severely damaged in a tornado. In 1999, a private individual purchased the airplane with the intention of restoring it. During the restoration process, the airplane was sold to the Liberty Foundation. The restoration was completed in 2004 and the airplane was returned to an airworthy condition. The FAA issued a limited special airworthiness certificate in May 2005. At the time of the accident, the airplane was being operated as a historical demonstration/exhibition aircraft by the Liberty Foundation.

The airplane was maintained under a progressive inspection program. The program was comprised of four incremental inspection procedures designated "A", "B", "C", and "D", which were to be conducted at 25-hour intervals, and periodic/non-routine inspection procedures as applicable. The most recent incremental inspections were completed on: March 25, 2011, at 2,501.9 hours total time airframe (TTAF); April 21, 2011, at 2,529.6 hours TTAF; May 14, 2011, at 2,552.7 hours TTAF; and June 10, 2011, at 2,579.0 hours TTAF.

Documentation on file with the Federal Aviation Administration (FAA) revealed that a modification of the fuel system was completed during restoration of the airplane. This modification involved removal of the outboard fuel cells, also known as "Tokyo" tanks, and related fuel lines. In addition, the fuel tank-to-fuel tank transfer system was replaced with a fuel tank-to-engine cross-feed system. A corresponding FAA form 337, Major Repair and Alteration, dated April 26, 2005, was on file with the airplane records.

An airplane maintenance logbook entry, dated February 24, 2011, at 2,474.7 hours TTAF, noted that the aluminum fuel tanks had been removed from the airplane, and that the rubber fuel bladder liners were removed from the tanks. The aluminum tanks were subsequently welded to close the bladder liner mounting relief holes and re-installed into the airplane. An operational check of the fuel tank modification did not reveal any anomalies and the airplane was returned to service. There was no corresponding Major Repair and Alteration (FAA form 337) on file with the airplane records. The mechanic that conducted the work noted that the fuel bladders were degrading and occasionally clogging the fuel sumps.

The final maintenance logbook entry was dated June 13, 2011, the day of the accident. The entry noted a repair to the inboard end of the no. 1 main fuel tank. A subsequent leak check did not reveal any anomalies and the airplane was returned to service.

The mechanic who accomplished the fuel tank repair reported that he had examined the no. 1 fuel tank the day before the accident because of a fuel leak. He determined that the leak was due a 3-inch crack that was located in the weld bead at the bottom edge of the tank near the sump drain valve. The fuel leak was repaired by installing 5 bolts through the fuel tank flange. An aluminum C-channel was then installed with sealant over the fuel tank flange. METEOROLOGICAL INFORMATIONAt 0952, the ARR Automated Surface Observing System recorded weather conditions as: Wind from 060 degrees at 10 knots; 10 miles visibility; clear skies; temperature 18 degrees Celsius; dew point 9 degrees Celsius; altimeter 30.16 inches of mercury. AIRPORT INFORMATIONThe accident airplane was a Boeing B-17G "Flying Fortress," serial number 44-85734. It was mid-wing monoplane design, configured with a retractable, tail wheel landing gear. The cockpit and cabin were accessible through a door located on the right side of the fuselage just forward of the horizontal stabilizer, or through a hatch located in the bottom of the fuselage below the cockpit. The airplane was powered by four 1,200 horsepower Wright model R-1820-97 nine-cylinder, radial engines.

Available information indicated that the accident airplane was delivered to the United States Army Air Force in 1945. In 1947, the airplane was included in a lot of aircraft sold for scrap. However, the accident airplane was not scrapped and was subsequently sold to the United Aircraft Corporation/Pratt & Whitney Aircraft Division for use as an engine development test bed. In 1967, the airplane was donated to the Connecticut Aviation Historical Association. Unfortunately, in 1979, the airplane was severely damaged in a tornado. In 1999, a private individual purchased the airplane with the intention of restoring it. During the restoration process, the airplane was sold to the Liberty Foundation. The restoration was completed in 2004 and the airplane was returned to an airworthy condition. The FAA issued a limited special airworthiness certificate in May 2005. At the time of the accident, the airplane was being operated as a historical demonstration/exhibition aircraft by the Liberty Foundation.

The airplane was maintained under a progressive inspection program. The program was comprised of four incremental inspection procedures designated "A", "B", "C", and "D", which were to be conducted at 25-hour intervals, and periodic/non-routine inspection procedures as applicable. The most recent incremental inspections were completed on: March 25, 2011, at 2,501.9 hours total time airframe (TTAF); April 21, 2011, at 2,529.6 hours TTAF; May 14, 2011, at 2,552.7 hours TTAF; and June 10, 2011, at 2,579.0 hours TTAF.

Documentation on file with the Federal Aviation Administration (FAA) revealed that a modification of the fuel system was completed during restoration of the airplane. This modification involved removal of the outboard fuel cells, also known as "Tokyo" tanks, and related fuel lines. In addition, the ...