N423RA

HISTORY OF FLIGHTOn September 21, 2012, about 1445 mountain daylight time, an experimental amateur-built Vans RV 7A, N423RA, was destroyed after colliding with terrain near the Laramie Regional Airport (LAR), Laramie, Wyoming. The airplane was registered to the pilot. The certified commercial pilot, who was the sole occupant, sustained fatal injuries. Visual meteorological conditions prevailed at the time of the accident, and an instrument flight rules (IFR) flight plan had been filed for the cross-country flight, which was being operated in accordance with 14 Code of Federal Regulations (CFR) Part 91. The flight departed the Duluth International Airport (DLH), Duluth, Minnesota, about 0926, with LAR as its destination.

The following is a chronology of the en route portion of the flight from DLH to LAR. All times are mountain daylight time (MDT), unless otherwise noted:

According to the airplane's en route radar track, the pilot departed on the 635 nautical mile (nm) instrument flight rules (IFR) cross-country flight at 0926, and arrived in the LAR area about 1441; the total time en route was 5 hours and 15 minutes. After takeoff the flight climbed and arrived at its initial cruising altitude of 8,000 feet mean sea level (msl) at 0934. At 1228, the flight ascended to 10,000 feet msl, and at 1339 it climbed to its final cruising altitude of 12,000 feet msl. The flight remained at this altitude until 1438, when it began its descent to LAR. The airport elevation at LAR is 7,842 feet msl. The radar data revealed that during the entirety of the flight, the airplane maintained a relatively consistent southwest course, which was in line with LAR.

In a conversation with the National Transportation Safety Board (NTSB) investigator-in-charge (IIC), a family member reported that the pilot had planned the cross-country trip to Laramie to visit another family member, and that the pilot had mentioned that he could probably make it without stopping en route to refuel, but that if he did stop it would most likely be in Scottsbluff, Nebraska. It was revealed during the investigation that the accident airplane did not make an en route refueling stop.

An initial report received by the NTSB IIC from Federal Aviation Administration (FAA) personnel revealed that witnesses to the accident reported that as the airplane approached LAR it overflew runway 21, then made left hand traffic for that runway. During its turn from base leg to final approach, which was estimated to be about one-quarter mile from the approach end of runway 21, the airplane impacted terrain. A subsequent fire erupted, which consumed the forward section of the airplane.

In a statement submitted to the NTSB IIC, an off-duty airline pilot who was driving by the airport on Highway 130, reported that he observed the airplane on what he assumed was final approach to Runway 21. The witness stated that when he first saw the airplane it was about 300 to 400 feet above ground level (agl), and just east of the highway, and [everything] looked normal. The witness opined that as the airplane crossed the highway there was some wing rock, like a small Dutch Roll. The witness revealed that when the airplane was about 100 to 150 feet agl the airplane's left wing dipped a little, then the right wing dropped very fast, which was followed by a spin to the right and impact with the ground at a very high [descent] rate. The witness added that the airplane hit nose down flat, with the right wing hitting just after the nose impacted the terrain. The airplane came to rest almost 180 degrees from its original direction. A fire then started, which consumed the airplane. The witness stated that the airplane never seemed to be in distress until the right wing dropped.

The wreckage was recovered to a secured facility for further examination. PERSONNEL INFORMATIONThe pilot, age 79, held a commercial pilot certificate, with ratings for airplane single-engine land and sea, multiengine land, and instrument airplane. The pilot also possessed a flight instructor certificate for airplanes, although it had been expired for several years. The pilot received his most recent second-class FAA airman medical certificate on April 18, 2011. The certificate contained the limitation that the pilot "Must wear corrective lenses for near and distant vision." On the application for his medical certificate, the pilot listed a total time of 5,000 hours, 40 hours flown in the previous 6 months. The pilot's personal logbook of flight times was not obtained during the investigation. Maintenance records revealed that the pilot had flown the airplane for 35.1 hours during its Phase One flight test requirements. No additional flight times for the pilot in make and model were noted. AIRCRAFT INFORMATIONThe accident pilot personally built the experimental RV 7A, which was a single-engine, side-by-side, tricycle gear kit airplane, serial number 71227. The airplane was equipped with a Lycoming IO-360-B1A engine, rated at 160 horsepower, and had a fuel capacity of 42 US gallons.

According to maintenance records provided by a family member, a FAA Designated Airworthiness Representative (DAR) issued the accident pilot a Special Airworthiness Certificate and Experimental Amateur-Built Operating Limitations on November 4, 2011. A review of the records also revealed that the first flight of the airplane was conducted on November 5, 2011, and that Phase One was completed on March 22, 2011, at a total time in service of 35.3 hours.

Fueling records were provided to the NTSB IIC by Monaco Air, which was located at DLH. According to the fuel records, the accident airplane was most recently refueled by Monaco on September 14, 2012. It was topped off with 12.5 gallon of 100 LOW-LEAD aviation fuel. METEOROLOGICAL INFORMATIONAt 1453, the LAR weather reporting facility reported wind 350 degrees at 14 knots, gusts to 24 knots, visibility 10 miles, sky clear, temperature 22° Celsius (C), dew point -4° C, and an altimeter setting of 30.28 inches of mercury. AIRPORT INFORMATIONThe accident pilot personally built the experimental RV 7A, which was a single-engine, side-by-side, tricycle gear kit airplane, serial number 71227. The airplane was equipped with a Lycoming IO-360-B1A engine, rated at 160 horsepower, and had a fuel capacity of 42 US gallons.

According to maintenance records provided by a family member, a FAA Designated Airworthiness Representative (DAR) issued the accident pilot a Special Airworthiness Certificate and Experimental Amateur-Built Operating Limitations on November 4, 2011. A review of the records also revealed that the first flight of the airplane was conducted on November 5, 2011, and that Phase One was completed on March 22, 2011, at a total time in service of 35.3 hours.

Fueling records were provided to the NTSB IIC by Monaco Air, which was located at DLH. According to the fuel records, the accident airplane was most recently refueled by Monaco on September 14, 2012. It was topped off with 12.5 gallon of 100 LOW-LEAD aviation fuel. WRECKAGE AND IMPACT INFORMATIONTwo FAA airworthiness aviation safety inspectors reported that their initial examination of the airplane at the accident site revealed that it had impacted level terrain about 400 feet northeast of the approach end of Runway 21. The attitude at impact was consistent with a steep right wing down, nose down attitude. A subsequent fire erupted, which consumed the cabin and cockpit areas of the airplane, as well as significant thermal damage to both wings.

Photographs provided to the NTSB IIC by the FAA inspectors revealed that the airplane had come to rest in an upright position oriented and facing to the southeast, or perpendicular to the extended centerline of Runway 21. While the empennage remained relatively intact aft of the aft cabin bulkhead, all areas forward of the bulkhead were destroyed or had been substantially damaged by impact and thermal damage.

An examination of the right wing revealed that it had separated from the fuselage and had sustained significant thermal and impact damage. Additionally, aft accordion crush signatures were observed to its forward outboard leading edge, consistent with the initial impact sequence confirmed by one witness. Both the wing's aileron and flap remained attached to the wing at all attach points. The wings fuel tank had been breached.

An examination of the left wing revealed that it had sustained significant impact damage and had partially separated from the left side of the airplane's fuselage. The inboard two-thirds of the wing was destroyed due to impact and thermal damage. The aileron was observed intact and attached to the wing's trailing edge at all attach points. Both the wing's aileron and flap remained attached to the wing at all attach points. The fuel tank was destroyed.

The engine, which had come to rest in an upright position and partially separated from its engine mounts, had sustained impact and thermal damage. The propeller had separated from the engine and was located about 30 feet to the east of the main wreckage. Both propeller blades remained attached to the propeller hub. A defined slash mark was evidenced by one blade having become buried in the terrain and not visible; the remaining blade was identified and remained above the surface. ADDITIONAL INFORMATIONThe airplane was equipped with two 21-gallon fuel tanks (42 gallons total), all of which, according to a Van's aircraft representative, was usable fuel. As previously noted, the investigation revealed that the airplane had been aloft for about 5 hours and 15 minutes when the accident occurred. According to the Lycoming Operator's Manual for the IO-320-B series engine, fuel consumption for Best Economy operating at 2600 revolutions per minute would be 8.8 gallons per hour (gph), 7.8 gph, 6.9 gph, and 6.1 gph at 75, 65, 55 and 45 percent power respectively. Additionally, total fuel consumption would have been 46.2, 41, 36.2 and 32...