Accident Details
Probable Cause and Findings
The mechanic's incorrect installation of two aileron cables and the subsequent inadequate functional checks of the aileron system before flight by both the mechanic and the pilot, which prevented proper roll control from the cockpit, resulting in the pilot's subsequent loss of control during flight. Contributing to the accident was the mechanic's and the pilot's self-induced pressure to complete the work that day.
Aircraft Information
Registered Owner (Historical)
Analysis
HISTORY OF FLIGHT
On May 7, 2015, at 1604 Pacific daylight time, a Piper PA 46-350P, N962DA, struck the Spokane River following an attempted landing at Felts Field Airport, Spokane, Washington. The airplane was owned by Flying Colors Aviation LLC, and operated by the pilot under the provisions of 14 Code of Federal Regulations Part 91. The commercial pilot and pilot rated passenger sustained fatal injuries and the airplane was destroyed during the impact sequence. The local flight departed Felts Field at 1553. Visual meteorological conditions prevailed and no flight plan had been filed.
The airplane had just undergone an annual inspection at the facilities of Rocket Engineering, and the accident flight was to be a post-maintenance test flight. Both the pilot and passenger were employees of Rocket Engineering, and the planned flight time was about 40 minutes.
Audio and radar data provided by the Federal Aviation Administration (FAA) captured the entire flight sequence. The accident was also observed by multiple witnesses at the airport, along with air traffic control personnel in the control tower.
The pilot specifically requested to depart from the longer Runway 4L, and 11 minutes after making the initial call, the airplane began the takeoff roll. Radar data indicated that almost immediately after takeoff it began a climbing turn, 10 degrees to the right. After flying on that heading for about 1.5 miles, the airplane began a more aggressive turn to the right, reaching 1,000 ft above ground level (agl) while on a southbound heading. The sound of labored breathing was then transmitted over the traffic advisory frequency, and the tower controller asked if everything was ok, to which the pilot responded, "That's negative". The airplane's turn radius then tightened to about 700 ft, and within about 45 seconds it completed almost two spiraling turns, while descending about 700 ft. Control tower personnel stated that during this period the airplane was banking about 90 degrees to the right and descending, and they assumed that it was about to crash. A short time later the bank angle began to reduce, and the airplane appeared to recover.
The airplane then began a meandering climb to the east, and about 2 1/2 minutes later the pilot reported, "We are trying to get under control here, be back with you".
The airplane eventually reached the town of Newman Lake, about 11 miles east of the airport, having climbed to about 5,600 ft mean sea level (4,000 ft agl), and the pilot reported, "things seem to be stabilizing", and when asked his intentions by the tower controller he replied, "We are going to stay out here for a little while and play with things a little bit, and see if we can get back."
The airplane began a gradual left turn, and the pilot requested and was approved for a straight-in landing for runway 22R. The airplane became aligned with the runway about 7 miles east of the airport, and a short time later the controller asked the pilot the nature of the emergency, to which he responded, "We have a control emergency there, a hard right aileron". The flight progressed, and a few minutes later the pilot reported that the airplane was on a 3 mile final. The airplane remained closely aligned with the runway centerline throughout the remaining descent, and control tower personnel stated that when the airplane neared the runway threshold it appeared to be flying in a 20-degrees, right-wing-low, attitude.
A tower controller reported that as the still-airborne airplane passed taxiway D, the engine sound changed, as if it was attempting to perform a go-around, and the airplane began a sharp roll to the right. It subsequently collided with the river just north of the airport.
PERSONNEL INFORMATION
The pilot-in-command, who was seated in the left front seat, held a commercial pilot certificate with ratings for airplane single engine land, multiengine land, rotorcraft-helicopter, and instrument airplane and helicopter, along with a flight instructor certificate for airplane single engine land. He also held a repairman, experimental builder certificate, and was rated in the Bell 212 helicopter, and Lockheed L-382 (C-130 Hercules) airplane.
His most recent FAA medical certificate was second class, and dated May 17, 2013, with the limitation that he must have available glasses for near vision. He was 64 years old. Representatives from Rocket Engineering stated the pilot had an appointment for his FAA medical examination at 0800 on the morning following the accident (Friday), and therefore chose to do the flight test that evening instead of the following day. The pilot's wife also stated that he typically did not work on Fridays, but would do so if work schedule required it.
The pilot had accumulated about 5,800 hours of total pilot-in-command flight time, 950 of which were in the accident make and model. He had flown about 20 hours in the accident make and model during the 30 day period leading up to the accident.
He was a retired Air Force Lieutenant Colonel, with 20 years of active service in the capacity of a test pilot, instructor, and search and rescue pilot.
The pilot was employed as an Engineer for Rocket Engineering, and was the primary liaison with the FAA's Flight Standards and Certification divisions. He also typically performed post-conversion, post-maintenance, and customer familiarization flights for the company.
The pilot-rated-passenger held a private pilot certificate with an airplane single engine land rating, issued in 2010. He had accumulated a total of about 122 hour's pilot-in-command flight experience.
He was employed at Rocket Engineering as a customer service and sales representative.
AIRCRAFT INFORMATION
The six-seat, low-wing, pressurized airplane was originally manufactured by Piper in 1996 as a PA-46-350P. At that time it was equipped with a Lycoming TIO-540-AE2A, 350 horsepower turbocharged piston engine. In 2007 it was modified by Rocket Engineering under the JetProp LLC supplemental type certificate ST00541SE, which included the installation of a 560 horsepower Pratt and Whitney PT6A-35 turboprop engine.
The airplane was brought to the facilities of Rocket Engineering on April 17 for an annual inspection. During the period leading up to the accident, routine maintenance was performed, along with the replacement of the four aileron cables in the wings, and an aft elevator cable. The mechanic who performed the work stated that the aileron and elevator cables were replaced during the 3 day period leading up to the accident.
The airplane's owner arranged for another maintenance facility on the field to perform an avionics upgrade concurrent with the inspection, while the airplane was still at the Rocket Engineering facilities. The president of the company that performed the avionics upgrade informed the owner that it would take about 40 to 45 hours to complete, over the course of about 18 days. The upgrade included the addition of several new avionics units, and according to the mechanic who performed the work, most was performed in the rear avionics bay, and required the removal of the aft headliner, along with the middle and rear seats on the right side in order to accommodate new electrical cable runs. The avionics shop president stated that as the upgrade progressed, the owner made multiple requests to add additional items to the work scope, and due to time constraints, not all of his requests could be accommodated.
The airplane's owner reported that he had made arrangements to pick up the airplane on May 5th, however as the work progressed, he was informed that the airplane would not be ready in time, and the date was pushed back to May 7 (accident day) and then May 8. He had made plans to travel up from Los Angeles the afternoon of May 7, and was enroute via a commercial airline when the accident happened.
METEOROLOGICAL INFORMATION
The weather conditions reported at Spokane at 1553 were winds from 020 degrees at 7 knots, 10 miles visibility with few clouds at 7,000 ft. The temperature was 71 degrees F, the dew point was 26 degrees F, and the altimeter pressure was 29.93 inHg.
WRECKAGE AND IMPACT INFORMATION
The river was about 25 ft deep at the accident site, and all major airframe components sank within a few minutes of impact. The airplane was recovered by a diving team from the Spokane County Sheriff's department over a 2 day period during the week following the accident.
The fuselage sustained crush damage and fragmentation from the firewall through to the right-side emergency exit door. The engine remained attached to the firewall, and the propeller hub with all four blades remained attached to the engine gearbox. All blades were bent about 90 degrees aft, 8 to 12 inches from their roots. Both wings had separated from the airframe at their roots, with the right wing separating into two sections outboard of the main landing gear. The horizontal stabilizer had detached from the tailcone.
MEDICAL AND PATHOLOGICAL INFORMATION
The Spokane County Office of the Medical Examiner performed an autopsy on both pilots. The deaths were both attributed to the effects of multiple blunt force injuries.
Toxicological tests on specimens recovered from both occupants were performed by the FAA Civil Aerospace Medical Institute (CAMI). Analysis revealed negative findings for ingested ethanol, with the following positive drug findings:
Pilot:
>> 10 (ug/ml, ug/g) Acetaminophen detected in Urine
>> Ranitidine detected in Urine
>> Ranitidine detected in Blood (Cavity)
Acetaminophen is a common-over-the-counter analgesic/antipyretic, and Ranitidine is an anti-histamine used in the treatment of gastric acid secretion. According to CAMI, neither of the drugs detected would have been considered hazardous to flight safety.
Pilot Rated Passanger:
>> Dextromethorphan detected in Urine
>> Dextromethorphan NOT detected in Blood (Cavity)
>> Dextrorphan detected in Urine
>> Dextrorphan NOT de...
Data Source
Data provided by the National Transportation Safety Board (NTSB). For more information on this event, visit the NTSB Records Search website. NTSB# WPR15FA158