N97119

On April 21, 2016, about 1445 Pacific daylight time, a Mooney M20K, N97119, was substantially damaged when it impacted terrain during an aborted takeoff from Woodland State Airport (W27), Woodland, Washington. The rear seat passenger was fatally injured, and the commercial pilot and the front seat passenger received serious injuries. The airplane was registered to MC AIR, Inc., and was being operated by the pilot as a Title 14 Code of Federal Regulations Part 91 personal flight. Visual meteorological conditions prevailed, and an instrument flight rules flight plan was filed for the cross-country flight, which was destined for Renton Municipal Airport (RNT), Renton, Washington. The flight was originating at the time of the accident.

The pilot flew from RNT to W27 with the front seat passenger the day before the accident to meet the rear seat passenger and other friends for a fishing trip. The fishing trip concluded about 1400 on the day of the accident, and the pilot and his passengers were dropped off at W27 by a friend.

The pilot reported that he occupied the left front seat; the passengers occupied the right front seat and the left rear seat. Before departing from the 1,953-ft-long runway, the pilot computed a takeoff ground roll of about 1,250 ft and a distance to clear a 50-ft-obstacle of about 2,200 ft. He gave a preflight briefing to the passengers that included instructions on operation of the seat belts; the engine start and run-up were "normal". Before takeoff, the pilot set the flaps to 10°, called out "seat belts," and advanced the throttle to 2,700 rpm and a manifold pressure of 39 inches while holding the brakes. He released the brakes and started the takeoff roll. The airplane lifted off after a ground roll of about 1,250 ft and climbed to about 35 ft above ground level but "then no longer seemed to accelerate as expected." The pilot lowered the nose and found that the airplane was "just above the ground." He retarded the throttle and flared the airplane into a nose-high attitude to avoid a "head on" impact with a berm, which was located about 415 ft beyond the departure end of the runway.

During an interview, the front seat passenger stated that the pilot watched him fasten his seat belt but did not provide a safety briefing to the passengers. He reported that the rear seat occupant was on his cellphone during the takeoff, but could not recall if the pilot announced "seat belts" before the takeoff roll. When the airplane was about 350 ft from the berm, the pilot announced that they were not going to make it. The airplane's nose rose before the airplane impacted the berm.

The pilot's friend, who witnessed and recorded a video of the accident, was located at the north end of the airport near the berm that the airplane impacted. The video showed that as the airplane approached the departure end of runway 32, it entered a slight nose-high attitude, and the left main landing gear lifted from the runway surface when the airplane was about 20 ft from the end of the runway. The video showed that the airplane reached an estimated maximum altitude of about 4 ft above the ground during the takeoff. In the video, after the airplane departed the asphalt runway, it maintained a nose-high attitude and then touched down in grass about 75 ft before it reached the airport perimeter fence, which was located about 375 ft beyond the runway end. During the time that the airplane was airborne, its estimated average groundspeed was about 65 knots. Sound spectrum analysis of the video indicated that the engine speed was constant about 2,430 rpm until the airplane impacted the fence and subsequently collided with the rising face of the berm.

PERSONNEL INFORMATION

The pilot, age 52, held a commercial pilot certificate with ratings for airplane single-engine land, airplane single-engine sea, airplane multi-engine land, and instrument airplane. He also held a flight instructor certificate with a single-engine airplane rating. The pilot's most recent Federal Aviation Administration (FAA) second-class medical certificate was issued on June 22, 2015 and included the restriction "must wear corrective lenses." According to the pilot's logbook, he had accumulated 2,915 hours of flight experience at the time of the accident, of which 46 hours were flown in the preceding 6 months. The pilot reported that he had accumulated about 100 hours of flight experience in the accident airplane make and model.

AIRCRAFT INFORMATION

According to FAA records, the airplane was manufactured in 1981 and registered to MC AIR on May 10, 2007. The airplane was powered by a turbocharged, direct-drive, air-cooled, 210-horsepower Continental TSIO-360-LB7 engine. A review of maintenance records revealed that the most recent 100 hour inspection was completed on September 30, 2015, at a hobbs time of 1,916 flight hours. At the time of the inspection, the engine had accrued 671 flight hours since major overhaul. The airplane had amassed 1,926 total flight hours at the time of the accident.

Takeoff Performance Information

The excerpts below from the airplane flight manual (AFM) show the procedures for a normal takeoff and an obstacle takeoff.

TAKEOFF (NORMAL)

1. Fuel boost pump – OFF

2. Alternate air – Push Closed

3. Parking brake – Push OFF

4. Engine oil temperature - 100° F minimum

5. Power – 40" MP and 2,700 rpm

6. Engine instruments – Check proper indications

7. Aircraft attitude – Lift nose wheel at 67 KIAS

8. Landing gear – Retract prior to 107 KIAS

9. Flaps – Retract in climb

TAKEOFF (OBSTACLE)

1. Fuel boost pumps – OFF

2. Alternate air – Push Closed

3. Parking brake – Push OFF

4. Engine oil temperature - 100° F minimum

5. Power – 40" MP and 2,700 rpm

6. Engine instruments – Check proper indications

7. Aircraft attitude – Lift nose wheel at 67 KIAS

8. Climb speed – 74 KIAS until clear of obstacle, then accelerate to 95 KIAS.

9. Landing gear – Retract in climb after clearing obstacle

10. Flaps – Retract after clearing obstacle

The AFM takeoff performance section includes charts for both ground roll and takeoff distance over a 50-ft obstacle. Both charts assume conditions that include 10° flaps, 40 inches manifold pressure, mixture full rich, and a paved level runway surface. These performance charts do not account for weights above the airplane's maximum gross weight of 2,900 pounds (lbs). Using the charts, the airplane's ground roll and takeoff distance over a 50-ft obstacle were calculated assuming an outside air temperature of 23°C and a gross weight of 2,900 lbs. As shown in Table 1, the airplane's zero-wind ground roll and takeoff distance over a 50-ft obstacle were about 1,350 ft and 2,300 ft, respectively. With a 4-knot headwind, the airplane's ground roll and takeoff distance over a 50-ft obstacle were about 1,200 ft and 2,200 ft, respectively. With a 6-knot tailwind, the airplane's ground roll and takeoff distance over a 50-ft obstacle were about 1,550 ft and 2,600 ft, respectively.

Table 1: Ground Roll and Takeoff Distance Chart

Weight and Balance

The AFM recovered from the airplane contained a weight and balance record dated May 23, 1994, that was marked as superseded on March 26, 2008, when avionics components were replaced. No weight and balance records with a more recent date than May 23, 1994, were found in the AFM. The airplane empty weight (EW) recorded on the May 23, 1994, weight and balance record was 1,945 lbs. Using the EW of 1,945 lbs, the pilot's weight of 206 lbs, the front seat passenger's weight of 284 lbs, the rear seat passenger's weight of 251 lbs, a fuel weight of 210 lbs, and a baggage weight of 83 lbs, the computed total weight was 2,978 lbs, which exceeded the maximum gross weight by 78 lbs. The occupant weights were derived from a combination of hospital reports and personal statements; the fuel weight was derived from the approximate fuel quantity drained from the airplane's wing tanks; and the baggage was weighed.

The pilot provided a weight and balance estimate for the flight, which he computed using a loading application on a portable electronic device. The pilot's inputs included an EW of 1,804 lbs, a combined weight of 530 lbs for the pilot and front seat passenger, a rear seat passenger weight of 200 lbs, a fuel weight of 210 lbs, and a baggage weight of 120 lbs. The pilot's computed total weight was 2,864 lbs. When asked where he obtained the EW of 1,804 lbs, the pilot replied that he retrieved this EW from the internet.

METEOROLOGICAL INFORMATION

The 1440 recorded weather at Paradise Point State Park, Ridgefield, Washington, located about 2.5 nautical miles (nm) southeast of W27, included wind from 290° at 2 to 4 knots, temperature 23°C, dewpoint 7°C, and an altimeter setting of 29.67 inches of mercury.

The 1459 recorded weather at St. Helens, Oregon, located about 4 nm southwest of W27 included wind from 131° at 1 to 6 knots, temperature 24°C, dewpoint 12°C, and an altimeter setting of 29.65 inches of mercury.

The 1453 recorded weather observation at Scappoose Industrial Airpark (SPB), Scappoose, Oregon, located about 9 nm southwest of W27, included wind from 070° at 4 knots, visibility 10 statute miles, clear skies, temperature 22°C, dew point 08°C, and an altimeter setting of 29.71 inches of mercury.

The resolution of the video frames from the recording made by the friend was sufficiently high for making wind-related observations. A windsock was located about 330 ft left of and before the end of the paved runway; it was about 730 ft from the camera. In addition to the windsock, the video also recorded trees and bushes on both sides of the runway. The video showed that the shape of the windsock corresponded to low wind speed, and did not show any visible motion of branches and leaves consistent with calm wind at the time of takeoff.

AIRPORT INFORMATION

W27 was located at an elevation of ...