N91NM

HISTORY OF FLIGHTOn September 17, 2016, at 0204 central daylight time, an Agusta (Leonardo) A109S helicopter, N91NM, impacted trees and terrain near Chandler Field Airport (AXN), Alexandria, Minnesota. The commercial rated pilot and two crew members sustained serious injuries and the helicopter was destroyed. The helicopter was registered to North Memorial Health Care and operated by North Memorial Air Care under the provisions of Title 14 Code of Federal Regulations (CFR) Part 135 as an air medical positioning flight. Night instrument meteorological conditions prevailed at the accident site and an instrument flight rules (IFR) flight plan had been filed. The helicopter departed Brainerd Lakes Regional Airport (BRD), Brainerd, Minnesota at 0137 and was destined for the Douglas County Hospital helipad, Alexandria, Minnesota, via AXN.

A review of the air traffic control (ATC) communications and radar data revealed that the pilot requested a clearance at 0135 and departed about two minutes later. Radar data indicated the helicopter climbed to 4,000 ft above ground level (agl) and flew southwest toward AXN. The radar data showed a generally straight and level flight with minimal altitude changes after the initial climb.

The pilot contacted ATC and requested to proceed direct to KILVE, the initial approach fix for the RNAV (GPS) approach to runway 22 at AXN. The controller cleared the pilot for the approach and instructed him to maintain 4,000 ft until established on the approach. One minute later ATC lost radar contact with the helicopter and instructed the pilot to report when established on the approach. Ten minutes later the pilot reported inbound on KILVE. Additional radar data later indicated that the helicopter made a slight left turn which corresponded to an extended line of the final approach course to runway 22. The controller, who was still not in radar contact with the helicopter, approved a frequency change and requested that the pilot report the cancellation of the IFR flight plan, to which the pilot acknowledged; no further communications from the pilot were recorded. Radar data later indicated that the helicopter remained on the final approach course while descending until the last radar target was recorded at 0201:06; 4.75 nautical miles from the runway about 2,050 ft agl. An onboard device recorded the accident flight coordinates; figure 1 shows the helicopter's final flight path.

Figure 1 – Final Flight Path

In a postaccident statement the pilot stated that he received a call for a flight about 0100; after a review of the weather conditions he accepted the flight and then filed an IFR flight plan to AXN. He was in radio contact with ATC, but radar contact was lost about half way through the flight. About 20 miles from AXN he noticed clouds quickly forming underneath the helicopter. He stated that ATC cleared the flight for the RNAV (GPS) 22 approach to AXN as clouds were still forming beneath the helicopter. With the landing sight not visible, he initiated a missed approach by utilizing the go-around function of the helicopter's autopilot and had 100% engine power applied. He stated that during the missed approach the helicopter made a quick 45° left bank so he applied right cyclic. Then the helicopter banked sharply to the right.

The flight nurse who was seated in the middle cabin, stated that the IFR flight to AXN was uneventful until they were near the airport. When the helicopter descended near AXN and he could see the runway lights beneath the helicopter through the fog. He couldn't determine the altitude of the helicopter because they were in the fog. He added that the pilot stated to the crew that they weren't going to break out of the fog and they would go-around. He did not know exactly why they needed to go around. He added that the helicopter banked to the right, then shuddered when the alarms and bells sounded. The helicopter shudder was "on the lighter side" of intensity, but he had never felt the helicopter shudder like that before. The engines sounded normal throughout the flight and he did not recall any unusual sounds or anomalies with the helicopter until the shudder. He did not remember if the helicopter entered a spin during the event.

The helicopter impacted the tops of several tall trees and the ground, then continued into a wooded area (figure 2). Several nearby residents were awake at the time of the accident and heard the helicopter's engines and then the sound of the impact.

Figure 2 – Accident Site

A review of the recorded flight data revealed that the flight path was in line with the GPS approach course and followed the respective waypoints. The helicopter intercepted the approach's last waypoint, WANBI, at 02:02:31 then the flight path started to deviate right of course (figure 3). The flight path continued toward AXN while maintaining the slight right deviation until 02:03:11 when the helicopter reached 1,840 ft, which is the approach's minimum descent altitude. Between 02:03:12 and 02:03:14 the collective position percentage increases, which is consistent with the reported go-around maneuver (figure 4). The helicopter descends to 1,740 ft until a climb began at 02:03:17. The helicopter climbed and turned right with a maximum bank angle of 50°. The flight path continued right as the helicopter then descended and the collective position continued to increase.

Figure 3 – Flight Path

Figure 4 – Flight Data Graph PERSONNEL INFORMATIONThe pilot was the Director of Operations for North Memorial Air Care.

In the preceding 6 months the pilot had accumulated 2.4 hours of flight time in actual instrument conditions, logged 11 precision instrument approaches, and 6 landings at night.

The North Memorial Operation's Manual stated that for recent night flight experience, each pilot is to abide by the requirements of 14 CFR Part 135.247(a)(2), which required in the preceding 90 days, he pilot must complete 3 takeoffs and 3 landings as the sole manipulator of the flight controls in the same aircraft category and class. The pilot had logged 6 night takeoffs and landings in the preceding 90 days. AIRCRAFT INFORMATIONOn June 12, 2015, the helicopter was equipped with a Spectrum Aeromed Medical Conversion Kit, supplemental type certificate (STC) SR02974CH, consisting of a base assembly with pivot, a stretcher, a medical attendant seat, and other medical components.

The helicopter was equipped with a GPS roll steering modification that featured a HEADING/GPS STEER switch, per an STC. The switch allows the pilot to manually select the heading (HDG) reference source. When the switch is selected to 'HEADING', the flight director (FD) computer calculates the necessary roll commands to bank the helicopter to intercept and maintain the heading selected on the electronic horizontal situation indicator (EHSI). With the switch selected to 'GPS STEER', the FD computer receives the heading error signal as computed by a dedicated STC box which compares the requested GPS heading and the actual heading. The FD transmits the calculated roll commands to the helipilot computers, which would in turn drive the pitch and roll rotary trim actuators to achieve the target attitude, rate, and heading.

In case of a malfunction or erroneous setting of the system, the A109S automatic flight control system (AFCS) has two different limiters in place to prevent excessive roll commands: one in the Flight Director computer, which imposes a max roll command in HDG mode of ±20°, when coupled to the AFCS for hands-off flying, and one in the helipilot computers, which had a target maximum roll attitude of ±24° and a maximum commanded roll rate of ±8.2° per second for short term stabilization purposes. METEOROLOGICAL INFORMATIONAt 0201, the AXN automated surface observing system (ASOS) recorded wind from 290 degrees at 10 knots, 9 miles visibility, scattered clouds at 400 ft, broken clouds at 3,600 ft, temperature 57 degrees F, dew point 57 degrees F, and altimeter setting 29.87 inches of mercury.

At 0209, the AXN the ASOS recorded wind from 290 degrees at 12 knots, 4 miles visibility, mist, broken clouds at 300 ft, temperature 57 degrees F, dew point 57 degrees F, and altimeter setting 29.87 inches of mercury.

An AIRMET Sierra for IFR conditions due to mist and precipitation was issued on September 16 at 2145 and was valid at the accident time.

A search of official weather briefing sources indicated the pilot used the ForeFlight application on his iPad at 0119 and received Lockheed Martin Flight Service weather briefing information in both text and graphical format. The weather information contained all valid AIRMETs, weather observations, and forecasts valid between the departure and destination airports; the pilot viewed the graphical images on his iPad. There is no record of the pilot receiving or retrieving any other weather information before the flight. AIRPORT INFORMATIONOn June 12, 2015, the helicopter was equipped with a Spectrum Aeromed Medical Conversion Kit, supplemental type certificate (STC) SR02974CH, consisting of a base assembly with pivot, a stretcher, a medical attendant seat, and other medical components.

The helicopter was equipped with a GPS roll steering modification that featured a HEADING/GPS STEER switch, per an STC. The switch allows the pilot to manually select the heading (HDG) reference source. When the switch is selected to 'HEADING', the flight director (FD) computer calculates the necessary roll commands to bank the helicopter to intercept and maintain the heading selected on the electronic horizontal situation indicator (EHSI). With the switch selected to 'GPS STEER', the FD computer receives the heading error signal as computed by a dedicated STC box which compares the requested GPS heading and the actual heading. The FD transmits the calculated roll commands to the helipilot computers, which would in turn drive the pitch and roll rot...