N4108F

HISTORY OF FLIGHTHISTORY OF FLIGHT

On August 27, 2019, about 1835 Pacific daylight time, a Cessna 172 airplane, N4108F, was destroyed when it was involved in an accident near McKenzie Bridge, Oregon. The pilot and the passenger were fatally injured. The airplane was operated as a Title 14 Code of Federal Regulations Part 91 personal flight.

According to the airplane owner, the pilot rented the accident airplane from 1730 to 1930 on the day of the accident. He indicated that he warned the pilot before departure of the high-density altitude that day and the potential for reduced airplane performance due to the high ambient temperatures. The pilot's exact departure time from Lebanon, Oregon (S30) was unknown.

A 16-second video file extracted from the pilot's mobile phone captured the accident flight about 10 minutes before the accident and showed the airplane flying through mountainous terrain at a low altitude. Toward the end of the video, the airplane made a slight right turn and then immediately began a left turn, at which point the video ended. The engine sounded smooth and continuous.

Several witnesses located under a tree canopy about midfield at McKenzie Bridge State Airport (00S), McKenzie Bridge, Oregon, saw the accident airplane as it flew into 00S. According to two of the witnesses, the airplane was about 5 ft above ground level (agl) flying east above runway 6 when it came into their view. One witness stated that he could not hear any noise as the airplane came into view and that the wingtips were rocking. Immediately after, he heard the sound of the engine power increasing, and the wings continued to rock. He indicated the airplane may have started to climb by the time it reached his center of vision, and about 1-2 seconds later it disappeared from his view. The second witness stated that she heard the engine running and that the wings rocked; the airplane then began a slow climb and disappeared from her view behind trees about 15-20 ft agl. A third witness, a helicopter mechanic, reported that the airplane appeared to be slow and was “way too low.” He said the engine sounded continuous at a low power setting. He stated that the airplane banked hard from side to side and then disappeared from his view behind trees. About 15 minutes later, two of the witnesses saw smoke coming from the accident site.

PERSONNEL INFORMATIONAccording to the pilot’s flight logbook, he began flight training in September 2018 and had 69.4 total flight hours by August 24, 2019, which was the final logbook entry. Most of his accumulated flight time was in the accident airplane make and model. The pilot's logbook did not contain any entries to indicate the pilot had accrued any experience with takeoffs and landings at mountain airports.

METEOROLOGICAL INFORMATIONLocal weather information was retrieved from a website operated by the University of Utah from a station located about 3 nautical miles west of the accident site. The station's 1806 weather entry showed wind 2 mph with gusts to about 8 mph from the northeast, temperature 98.4°F, and dewpoint 41°F.

The calculated density altitude at 00S was about 4,481 ft mean sea level about the time of the accident.

WRECKAGE AND IMPACT INFORMATIONThe airplane came to rest inverted in a wooded area about 615 ft east of the departure end of runway 6. The initial impact point (IIP) was marked by a tree about 120 ft tall with a severed top. (See Figure 1) A section of the left wingtip was found about 40 ft southwest of the IIP and displayed a depression in the leading edge of the wingtip. An intermediate impact point was observed along the debris path and marked by several broken tree branches at the top of a tree about 120 ft tall, about 75 ft southeast of the IIP. The main wreckage was located about 150 ft from the IIP and was mostly consumed by the postcrash fire but comprised all major structural components of the airplane.

Figure 1: Wreckage Path Diagram

Figure 2: Terrain Elevations along Flight Path

Most of the flight control linkages remained attached to their respective control surfaces. and control continuity was traced from the rudder, elevator, and aileron to the cockpit. The elevator trim actuator measured 1.2 inches, consistent with a neutral trim setting.

The propeller was thermally damaged and remained attached to the engine crankshaft. One propeller blade was separated near the blade root with a slight aft bend but did not display any striations, nicks, or gouges; the other propeller blade remained attached and did not display any damage.

Rotational continuity of the engine and valvetrain could not be achieved because the engine crankcase and accessories were damaged by postcrash fire and the oil sump was destroyed. Although the crankshaft, camshaft, connecting rods, and piston were mostly damaged by postcrash fire, an examination of these components and the interior engine case revealed no indications of catastrophic engine failure.

MEDICAL AND PATHOLOGICAL INFORMATIONThe Oregon State Medical Examiner's Office, Clackamas, Oregon, performed an autopsy of the pilot. The pilot's cause of death was blunt force injuries and immolation due to light plane crash. No significant natural disease was identified.

The FAA's Forensics Sciences Laboratory performed toxicology testing on the pilot's tissue samples, which detected no evidence of ethanol or drugs of abuse.

TESTS AND RESEARCHThe airplane's takeoff performance was calculated using the takeoff and climb charts from the pilot's operating handbook for the airplane’s make and model. A postaccident weight and balance calculation used the pilot's weight at his last medical examination of 134 lbs, an estimated passenger weight of 170 lbs, and fuel weight of 108 lbs; the airplane's gross weight was calculated to be about 1,700 lbs and the moment was about 66,000-inch lbs, which placed the airplane in the utility envelope. The takeoff distance chart assumed that flaps were retracted, and the takeoff was being conducted on a hard surface runway. According to calculations based on data in the takeoff chart, the airplane would have required a ground run of 744 ft and a total takeoff distance of about 1,330 ft to clear a 50-ft obstacle at a field elevation of 5,000 ft and an ambient temperature of 41°F. The chart showed that had the airplane been operating at its maximum gross weight of 2,200 lbs, it would have required a total takeoff distance of 2,455 ft at the same field elevation and ambient temperature to clear a 50-ft obstacle.