N4089R

On August 19, 2020, about 1215 eastern daylight time, a Piper PA-32-300, N4089R, was substantially damaged when it was involved in an accident at Tallahassee International Airport (TLH), Tallahassee, Florida. The pilot incurred minor injuries and the two passengers were not injured. The airplane was operated as a Title 14 Code of Federal Regulations Part 91 personal flight.

According to the pilot, he performed a preflight inspection of the airplane with no anomalies noted and loaded the airplane for the flight. He knew that the airplane had about 60 gallons of fuel on board, since he flew a trip the previous week and used the fuel out of the left main tank. He performed the accident flight with the right main fuel tank selected. The engine started up, ran without issue, until the engine run-up when it "backfired." The pilot continued to perform the engine run-up by checking the magnetos and letting the engine continue to run, and no other issues were noted.

The pilot taxied onto the runway and slowly increased engine power. After rotation, the pilot noticed that the tachometer did not indicate full engine rpm, and also noted that the engine was not producing power. Since the airspeed was slow and close to the stall speed, the pilot attempted to descend in order to increase the airspeed; however, the airplane was "already stalling." It "pancaked" onto the runway and veered off the right side striking the visual approach lighting system with the right wing. During the accident sequence, the right wing incurred substantial damage.

After the accident, the pilot provided a weight and balance calculation for the flight, which revealed that the airplane was within load limits for the flight.

An engine examination was performed by an NTSB investigator after the accident. The top spark plugs were removed from the engine and no anomalies were observed with their electrodes. The crankshaft was rotated by hand and valvetrain continuity was confirmed to the rear accessory section. Additionally, thumb compression was confirmed on all cylinders. The number 3 cylinder fuel injector was examined and found to be absent of debris or deposits. Fuel was plumbed from an external fuel tank into the engine. The engine started immediately, accelerated smoothly, and ran continuously without interruption.

The airplane was equipped with a JPI EDM-700 engine data monitor. Examination of data from the unit revealed that the recording associated with the accident flight began around 1207. The exhaust gas temperatures (EGT) for all six cylinders followed rough relative patterns of increase and decrease until about 1214:30, when the number 3 cylinder EGT began intermittently rapidly increasing and decreasing until just before 1217. Also during this time the cylinder head temperatures (CHT) for all six cylinders gradually rose at a relatively uniform rate until from the start of the data until about 1217, when the number 3 CHT began a steady decrease while the remaining 5 cylinders continued their gradual increase in temperature. About 1218, the engine rpm increased gradually over about 30 seconds to about 2,300, then reached a maximum of about 2,400 rpm shortly after 1219. The rpm then rapidly decreased around 1930. Review of 3 previous flights revealed that the engine rpm maximum recorded was about 2,700 rpm, compared to 2,400 achieved during the accident flight.