N400SL

HISTORY OF FLIGHT

On September 9, 2002, at 2152 central daylight time (cdt), a Bell 206L-1 helicopter, N400SL, piloted by a commercial pilot, was destroyed during a collision with terrain about 3.6 nautical miles (nm) southeast of Doland, South Dakota. Night marginal visual meteorological conditions (MVFR) prevailed at the time of the accident. The flight was operating under the provisions of 14 Code of Federal Regulations (CFR) Part 135 while on a company flight plan. The pilot, flight nurse, flight paramedic, and patient were fatally injured. The flight departed from Avera St. Luke's Hospital (SD54), Aberdeen, South Dakota, at 2131 and was en route to Heart Hospital of South Dakota Heliport (2SD6), Sioux Falls, South Dakota.

The helicopter was operated by Omniflight Incorporated, an on-demand air ambulance service. According to company personnel, the flight from SD54 to 2SD6 was considered a routine flight and the accident pilot was familiar with the route. The route was normally flown direct from SD54, navigated by pilotage and augmented with a global positioning system (GPS) receiver. When flying GPS direct, the helicopter passes over Doland.

According to company dispatch records, the helicopter departed SD54 and proceeded directly toward 2SD6. At 2149:49 (hhmm:ss), the company dispatcher asked the pilot for a position report. The pilot replied that there were four individuals on-board the helicopter, that the helicopter had two hours of fuel remaining, and that the estimated time en route (ETE) was 58 minutes. The dispatcher confirmed the pilot's transmission, including the 58 minute ETE. The pilot's position report placed the helicopter near Doland, according to company pilots familiar with the route.

At 2151:11, the pilot relayed the crew identification numbers to the dispatcher. At 2151:16, the dispatcher repeated the crew identification numbers and the pilot replied, "affirmative." There were no additional transmissions received from the accident helicopter.

Several Doland area residents witnessed the accident helicopter flying over the town around 2150. The witnesses reported that the helicopter was flying southeast over the town approximately 300 - 500 feet above ground level (agl). One witness reported that the helicopter "seemed to be running fine." Another witness reported that the helicopter was "a little slower...than normal."

One of the witnesses reported that "the sky was overcast, but the clouds were breaking up as [he] noticed stars becoming visible. It had rained earlier in the evening, but at least by [2130 cdt] it was not raining." Another witness reported that "the clouds were starting to break up [and] it was clearing in the west but clouds were present in the east."

DAMAGE TO AIRCRAFT

The helicopter was destroyed by impact forces with terrain.

PERSONNEL INFORMATION

According to Federal Aviation Administration (FAA) records, the pilot, age 39, held a commercial pilot certificate with rotorcraft/helicopter, airplane single engine land (SEL), and helicopter/airplane instrument ratings. The pilot also held a certified flight instructor (CFI) certificate with rotorcraft/helicopter, SEL, and helicopter/airplane instrument ratings. The pilot's last FAA medical examination was completed on February 4, 2002, when he was issued a second-class medical certificate with the limitation "shall wear corrective lenses." The pilot was a Japanese citizen working in the United States as a registered permanent resident.

According to the pilot's flight records, he had accumulated 2,670.3 hours of flight experience, with 2,572.2 hours in helicopters and 98.1 hours in SEL airplanes. The pilot had logged 2,338.4 hours as pilot-in-command (PIC), of which 2,062.0 hours were as a helicopter flight instructor.

The pilot had 140.5 hours of night experience, with 129.2 hours in helicopters and 11.3 hours in airplanes. He had logged 91.0 hours of night cross country flying, including 79.7 hours in helicopters. A review of the pilot's flight logbooks indicated a majority of his night experience was completed near major metropolitan areas while providing flight instruction.

The pilot had 56.8 hours of instrument experience in both helicopters and airplanes. He had logged 10.2 hours in actual instrument conditions and 46.6 hours in simulated conditions. The pilot had 20.4 hours of instrument time in helicopters, all of which were in simulated conditions.

A majority of the pilot's helicopter experience, 2,249.5 hours, was completed in the Robinson R-22. The pilot had also accumulated 321.2 hours in the Bell 206, 1.0 hour in the Aerospatiale AS-350 and 0.5 hours in a Bell 47.

The pilot had flown 244.2 hours in helicopters during the past year, consisting of 130.2 hours in Bell 206 helicopters and 114.0 hours in Robinson R-22 helicopters. He flew 81.4 hours during the prior 6 months, 51.1 hours during the past 90 days, and 1.6 hours during the previous 30 days. The pilot did not fly during the 24 hours before the accident flight.

The pilot worked 17 twelve-hour shifts during the previous 30 calendar days. The pilot reported for duty on September 9, 2002, at 1900, after being off-duty for 12 hours.

- Flight Training History

The pilot began his primary helicopter flight training on September 6, 1991, and obtained a private pilot certificate on December 13, 1991. He continued his flight training and obtained his commercial pilot certificate on March 16, 1992, and his CFI certificate on May 13, 1992. On August 25, 1992, the pilot began helicopter flight instruction in Japan and obtained a Japan Civil Aviation Bureau (JCAB) commercial helicopter license on March 3, 1993.

On August 6, 1999, the pilot began airplane flight instruction in the United States and obtained a FAA private pilot rating for SEL airplanes on September 10, 1999. He then began instrument airplane flight instruction. On April 20, 2000, the pilot did not pass an airplane instrument practical exam and received a Notice of Disapproval of Application. According to FAA records, during the examination the pilot became disoriented while flying instrument approaches and the flight examiner had to take control of the airplane. The pilot also incorrectly selected the radial for a VOR approach and missed the airport by several miles. On two occasions during the flight the examiner had to explain air traffic control clearances to the pilot.

After the checkride the pilot did not fly airplanes until February 2, 2001, when he resumed taking instrument instruction again. The pilot successfully obtained his airplane instrument rating on February 28, 2001. He continued to receive airplane flight instruction and obtained a commercial SEL airplane rating on March 23, 2001, and a CFI SEL airplane rating on April 3, 2001. On November 6, 2001, the pilot received a CFI instrument airplane rating.

The pilot took two FAA practical examinations on November 19, 2001. The first practical exam was to add a helicopter instrument rating to his commercial certificate. The pilot satisfactorily passed the practical examination for the helicopter instrument rating. The second practical exam was to add a helicopter instrument rating to his flight instructor certificate. The pilot did not pass the practical exam and received a Notice of Disapproval of Application. According to FAA records, the pilot demonstrated unsatisfactory knowledge of ATC procedures and clearances. The pilot obtained his instrument helicopter instructor rating on December 04, 2001, after successfully completing the practical exam on the second attempt.

- Aviation Employment History

The pilot came to the United States to work as a helicopter flight instructor, in January 1994. He was initially employed by Puget Sound Helicopters, Renton, Washington. In May 1997, he began providing flight instruction for Kyodo Air Incorporated, Paso Robles, California. Between September 1997 and January 2002, the pilot was the Director of International Training for Hillsboro Aviation Incorporated, Hillsboro, Oregon. He also provided helicopter flight instruction and was a helicopter charter pilot (14 CFR Part 135) while employed by Hillsboro Aviation.

On January 17, 2002, the pilot was hired by Omniflight Helicopters Incorporated, based in Addison, Texas. When hired the pilot had 2,464.1 hours of helicopter flight experience, of which 213.1 hours were in a Bell 206. The pilot had 112.8 hours of night experience in helicopters, including 69.7 hours of night cross country. He had 18.6 hours of instrument time, all of which was simulated instrument time.

The pilot began indoctrination flight training on January 23, 2002, and was approved for 14 CFR Part 135 operations after passing a FAA Airman Competency/Proficiency Check on January 25, 2002. On February 16, 2002, the pilot reported for duty at the Omniflight base in Aberdeen, South Dakota.

During February 2002, the pilot's ability to perform night missions was evaluated by the base manager, base safety manager, and a company check airman. The safety manager reported that "it became apparent that [the pilot] had not flown over an area that was dark, or void of lights. Every time [the pilot] turned right he went into a dive and every time he turned left he went into a climb." The safety manager stated that the pilot also had difficulties operating the search light, determining wind direction and helicopter heading, and making routine radio calls. The base manager decided to restrict the pilot to day-missions only.

In June 2002, a newly appointed base manager flew with the pilot to determine his ability to fly night missions. On June 9, 2002, the base manager wrote an e-mail to the company chief pilot in which he raised concerns about the pilot's ability to fly night missions. The e-mail stated, "I believe [the pilot] lacks the proficiency to multi-task instrument cross check while operating the search light...