N9257X

HISTORY OF FLIGHT

On March 5, 2003, approximately 1650 mountain standard time (MST), a Piper PA-34-220T, N9257X, impacted the terrain while on a visual flight rules final approach to Madison County Airport, Rexburg, Idaho. The commercial pilot and his three passengers received fatal injuries, and the aircraft, which was owned and operated by the pilot, was destroyed. The 14 CFR Part 91 personal pleasure flight, which departed Lamar, Colorado, about 1222, was operating in visual meteorological conditions at the time of the accident. The flight had been on an Instrument Flight Rules (IFR) flight plan, but the pilot had canceled the flight plan at 1634.

On the morning of the flight, prior to his departure from Shreveport, Louisiana, the pilot contacted the FAA's Automated Flight Service Station and received a weather briefing for both legs of the trip he planned to take that day. The first portion of the briefing addressed his planned route from Shreveport to Colorado Springs, Colorado, and the second portion addressed the route from Colorado Springs to Rexburg. The pilot departed Shreveport at 0854 central standard time for the first leg of the flight, but ultimately decided to divert into Lamar, Colorado, which was 100 nautical miles closer to his point of departure. He advised the Denver Center controller that the reason for the diversion was that higher than expected winds were slowing his progress and he "didn't want to take a chance on fuel." FAA records show that the pilot was cleared for an approach at Lamar at 1120 MST, and that he canceled his IFR flight plan at 1120. Although his exact landing time was not determined, he made a telephone call to the Denver Automated Flight Service Station at 1149, ten minutes after canceling his flight plan.

Upon making contact with Flight Service, the pilot confirmed that his IFR flight plan had been canceled, and then refiled the flight plan for the second leg of the trip, with a departure point of Lamar instead of Colorado Springs. During that filing, he stated that he would be departing Lamar about 1200 MST, and that the expected time en route would be three hours and thirty minutes. He also advised the briefer that he had five hours of fuel on board, based upon a true airspeed of 175 knots. Prior to departure, the aircraft fuel system was " topped off" by adding 103.8 gallons of low lead aviation fuel.

Several witnesses observed the aircraft prior to the accident. One witness located on the airport, and monitoring the Unicom frequency, reported that the pilot radioed his position with the intention of entering a left downwind for runway 17. Although the position of that downwind appeared normal, the aircraft stayed on the downwind leg long enough that when it turned from base leg to final approach, it was three to four miles from the end of the runway. It was then seen to proceed inbound on final approach on a vertical approach path that was significantly lower than what other aircraft normally used when landing on this runway. When the aircraft was just over a mile from the end of the runway, at an estimated altitude of 200 feet above the ground, it suddenly rolled steeply to the right and made a descending turn into the terrain. The pilot, who had been making normal position calls, both prior to and after entering the pattern, did not indicate that he was having any problem with the aircraft.

Other witnesses in the vicinity of the airport reported seeing the aircraft approach the runway "low" and with a "severe crab angle." Each of the witnesses commented on the high wind condition at the time and indicated that the plane made a right turn and descended to the ground.

PERSONNEL INFORMATION

At the time of the accident, the pilot held a private pilot certificate for single-engine land and sea aircraft, and a commercial certificate for multi-engine land aircraft and instrument airplane operations. A review of the pilot's flight logbook indicated a total flight time of approximately 800 hours. The first entry noted in the logbook for the accident aircraft was in November 2001. Since this time, the pilot had accumulated approximately 177 hours in this aircraft. A total of approximately 450 hours had been accumulated in multi-engine aircraft.

On September 27, 2002, the pilot's flight logbook indicated entries for successfully completing the required training of 14 CFR Part 61.31(g), and it was determined that he was proficient in the operation and systems of a pressurized aircraft. The pilot also on this day, satisfactorily completed training requirements outlined in Advisory Circular 61.91H, paragraph 7a, for the Pilot Proficiency Award Program, and satisfactorily completed the Instrument Proficiency Check requirements of 14 CFR Part 61.57(d).

AIRCRAFT INFORMATION

Aircraft records indicated that the pilot purchased this aircraft in May 2000. A review of maintenance records indicated that the aircraft had been signed off for an annual inspection on April 1, 2002, at a total airframe time of 1039.1 hours. Approximately 163 hours had been accumulated on the aircraft since the last annual inspection. The engine logbooks indicated that both engines also had a total time since new of 1039.1 hours at the time of the annual inspection.

METEOROLOGICAL INFORMATION

At 1653, the surface weather observation at the Rexburg Airport was reporting a wind from 210 degrees at 24 knots, with gusts to 36 knots. The temperature was 37 degrees F and the dew point was 21 degrees F. Visibility was 10 miles with few clouds at 4,200 feet and scattered clouds at 8,000 feet. The altimeter setting was 29.56" Hg.

COMMUNICATIONS

Air traffic control communications and radar data provided by the Federal Aviation Administration Salt Lake City, Utah, Air Route Traffic Control Center, indicated that the flight had been cleared to proceed direct to Lorrn Intersection at 1613 and was cleared to descend. At 1616, the pilot reported to air traffic that the aircraft was picking up mild rime ice on the wings and windshield. At 1627 the controller instructed the pilot to cross Lorrn Intersection at or above 8,000 feet and that they were cleared for the GPS runway 35 approach to Rexburg. The pilot responded to the controller inquiring if there was a possibility of getting down to 9,000 feet due to the mixed ice and "fuel situation." Further communications with the pilot and controller indicated that the pilot misunderstood the controller about the altitude clearance. The controller then instructed the pilot to report Lorrn Intersection inbound on the approach.

At 1629, radar data indicated that the flight was descending out of 10,300 feet and tracking in a westerly direction toward Lorrn Intersection. In the vicinity of Lorrn Intersection, at 1634 and 8,300 feet, the pilot reported to air traffic that he wanted to cancel the IFR flight plan and proceed direct to Rexburg. The controller verified the IFR cancellation and instructed the pilot to squawk VFR. There were no further communications with air traffic control after this time.

Lorrn Intersection is located on the 16 degree radial from the Idaho Falls, Idaho, VOR, 14.7 Distance Measuring Equipment (DME) miles, on the 132 degree radial from the Dubois VOR, 25.7 DME miles, and 7 nautical miles southwest of Rexburg Airport.

WRECKAGE AND IMPACT INFORMATION

The wreckage was located in an open level field used for crops. The accident site coordinates were obtained via a hand held GPS unit. The coordinates were N 43 degrees 50.938 latitude, W 111 degrees 48.416 longitude. The elevation at the accident site via the GPS was 4,930 feet. The airport that was located approximately 140 degrees magnetic and one mile from the accident site is 4,858 feet. The ground was hard packed/frozen. Above-ground irrigation sprinklers ran in rows perpendicular to the wreckage distribution path. The aircraft collided with three of the sprinkler runs that were spaced about 25 feet apart.

The wreckage distribution path was measured from the initial ground disturbance to the resting place of the main wreckage. The magnetic heading was 360 degrees. Within the first ground disturbance a fragment of the right wing green lens cover was located along with paint chips. The ground disturbance had the appearance of being "sliced." The remainder of the ground disturbance continued throughout the rest of the path as mainly "sliding over the surface" signatures which was reported as hard and frozen at the time of the accident.

Approximately 26 feet from the initial point, another shallow ground impact crater was noted. Within this approximate three foot in length disturbance a propeller hub was embedded in the ground. P/N P5095227-0 McCauley propeller was noted.

Approximately 51 feet from the initial point, all six-propeller blades were located separated from their respective hubs and in close proximity to each other. This area was also the beginning of the collision with the sprinkler pipes. From this point to the main wreckage, the path was littered with articles of clothing, cowling fragments and miscellaneous items.

The main wreckage was located 229 feet from the initial impact point. The fuselage was positioned inverted and pointing in a westerly direction.

The outboard 10 feet of the right wing had separated, outboard of the right engine, and was located within ten feet of the main wreckage. The entire length of the aileron remained attached at all three hinges. The leading edge tip of the wing displayed a 45-degree aft crush. The wing tip cap was located about mid point in the wreckage distribution path. The inboard section of the right wing, inboard of the engine was severely damaged with only electrical wiring and control cables holding the engine and nacelle in place. The flap remained in place but was bent. The right engine remained partially attached to the wing structure and was also positioned inverted....