N537Z

1.1 HISTORY OF FLIGHT

On May 24, 2003, at 1225 Pacific daylight time, a North American T28C, N537Z, collided with terrain following an in-flight loss of control after takeoff near Sherman Oaks, California. The accident site was about 4 miles southeast of the Van Nuys Airport (VNY), Van Nuys, California, and the flight's departure point. The owner/pilot was operating the airplane under the provisions of 14 CFR Part 91. The commercial pilot and one passenger were fatally injured; the airplane was destroyed. The personal cross-country flight departed at 1222, en route to Thermal, California. Day visual meteorological conditions prevailed below a solid overcast; the cloud layer base varied between 1,300 and 1,700 feet mean sea level (msl), and tops of the cloud layer were reported between 3,000 and 3,500 feet msl. An instrument flight rules (IFR) flight plan had been filed. The primary wreckage was at 34 degrees 08 minutes north latitude and 118 degrees 25 minutes west longitude.

Witnesses near the accident site reported that they saw the accident airplane coming out of the clouds from the southwest at a high rate of speed, and in a steep nose down attitude. Witnesses also said the radial engine sounded normal. The airplane continued to make noise until impact, which was followed by a post impact explosion.

Information obtained from the Federal Aviation Administration (FAA) indicated that the Southern California Terminal Radar Control (SCT) handled the flight during the accident sequence. According to a review of the air and ground communications tapes, the pilot checked in with the sector controller after being handed off from the Van Nuys tower controller. The pilot contacted the sector controller and reported climbing through 1,600 feet. The controller stated that the airplane's secondary beacon target (Mode C) showed 1,400 feet. About 1 minute later the pilot was issued an amended clearance from 3,000 feet to 4,000 feet. The pilot reported that he was "leaving 3,000 feet." Shortly thereafter, radio and radar contact were lost with the flight.

During the entire flight, the total number of Mode C altitude radar returns were 33. Of those, 14 radar returns indicated zero feet, 5 were at 1,300 feet, 11 were 1,400 feet, and 3 were reported at 4,100 feet.

1.2 PERSONNEL INFORMATION

A review of FAA airman records revealed the pilot held a commercial pilot certificate with ratings for airplane single and multiengine land and instrument airplane.

A review of the FAA medical records revealed that the pilot held a second-class medical certificate that was issued on January 21, 2003. It had limitations of "holder shall wear corrective lenses."

No personal flight records were located for the pilot. The aeronautical experience listed in this report was obtained from a review of the FAA airman and medical records on file in the Airman and Medical Records Center located in Oklahoma City, Oklahoma. These records indicated as of January 21, 2003, a total flight time of 2,350 hours, with 50 hours logged in the last 6 months.

Training records for the accident pilot were obtained from Flight Safety International. The records indicated that the pilot had completed a recurrent course for the Cessna 300/400 series aircraft per Federal Aviation Regulations (FAR) 61.56 on July 20, 2002. The pilot indicated on his training records he was current for instrument flight, per FAR 61.57(c). In these training records the pilot indicated as of July 20, 2002, a total flight time of 2,350 hours, with 75 hours logged in the last 6 months, and 850 hours total time in the T-28C.

1.3 AIRCRAFT INFORMATION

The airplane was a North American T28C, N537Z, serial number 140537. The airplane was issued a special purpose airworthiness certificate on May 31, 1991, in the experimental category for exhibition and racing. A review of the airplane's logbooks revealed a total airframe time of 8,675.7 hours at the last periodic inspection. The inspection was completed on March 14, 2003. The Hobbs hour meter read 884.0 at the last inspection. The Hobbs hour meter was destroyed.

The airplane had a Wright R-1820 86A engine, serial number BL520727. Total time on the engine at the last periodic inspection was 268.0 hours.

Examination of the maintenance records revealed no unresolved maintenance discrepancies against the airplane prior to the accident flight.

During interviews with maintenance personnel and pilots who had flown the accident airplane, they stated that the transponder was located on the right side rails of the forward cockpit. The pilot would have to look down, to the right, and aft to alter any settings on the transponder during flight.

1.4 METEOROLOGICAL INFORMATION

A staff meteorologist for the National Transportation Safety Board prepared a factual report, which included the following weather for the departure area.

There were three surface weather stations in the vicinity of the accident site. These stations included Van Nuys (KVNY), Burbank (KBUR), and Santa Monica (KSMO). All three California stations had an Automated Surface Observing System (ASOSs). KVNY and KBUR were located about 6 miles away from the accident site at 331 degrees and 29 degrees, respectively. KSMO was about 7 miles away at 192 degrees. The elevations of KVNY, KBUR, and KSMO stations are 797, 774, and 173 feet, respectively.

Van Nuys, California

Time-1851Z to 1951Z:

Winds were from 160 degrees between 4 and 5 knots; visibility was between 5 and 6 statute miles; sky conditions were overcast between 1,500 and 1,700 feet; temperatures were between 61 degrees Fahrenheit and 63 degrees Fahrenheit; dew point was 55 degrees Fahrenheit; and altimeter settings were between 29.94 inches of Mercury (inHg) and 29.95 inHg.

Burbank, California

Time-1853Z to 1953Z:

Winds were between calm and variable at 5 knots; visibility was 4 statute miles; sky conditions were overcast between 1,100 and 1,300 feet; temperature was 61 degrees Fahrenheit; dew point was 55 degrees Fahrenheit; and altimeter setting was 29.95 inHg.

Santa Monica, California

Time-1851Z to 1929Z:

Winds were between 210 to 220 degrees at 5 to 8 knots; visibility was between 9 to 10 statute miles; sky conditions were overcast between 900 and 1,100 feet; temperature was 61 degrees Fahrenheit; dew point was 55 degrees Fahrenheit; and altimeter setting was 29.96 inHg.

1.5 COMMUNICATIONS

Safety Board investigators reviewed the recorded radio communications between N537Z and Van Nuys ATC ground, Tower and Southern California Terminal Radar Control (SCT).

At 1907Z, N537Z contacted VNY ground control; requested and received clearance to taxi for takeoff. Nine minutes later, N537Z requested and received an IFR clearance; IFR to VFR on top and VFR to Thermal, California.

At 1920Z, N537Z was cleared for takeoff. Two minutes later, VNY tower advised N537Z to contact SCT. The pilot of N537Z reported to SCT he was climbing out of 1,600 feet for 3,000 feet.

SCT observed that the Mode C altitude for N537Z was 1,400 feet. Forty-five seconds after N537Z reported in, SCT advised him of the Mode C error and to "squawk altitude." Twenty seconds later SCT asked N537Z to verify he was climbing out of 1,400 feet. N537Z responded "leaving 2,300" feet.

Ten seconds later, SCT requested N537Z recycle the transponder. N537Z reported the "Mode C is on." Twenty-seven seconds later, SCT told N537Z to turn left to a heading of 040 degrees. N537Z acknowledged the transmission. Eight seconds later, SCT advised N537Z to stop the altitude squawk and climb and maintain 4,000 feet, and to report the altitude he was climbing out of. N537Z reported "out of 3,000" feet.

At 1924:05Z, N537Z asked SCT, "was that a left or right turn to 040?" (SCT was on the landline and did not answer). At 1924:13Z, the Mode C altitude report was 4,100 feet. Eight seconds later, SCT asked N537Z "what is your altitude?" There was no response from N537Z.

At 1924:22Z, the last Mode C altitude report was 1,400 feet. The last radar report was in the area of the accident site.

1.6 WRECKAGE AND IMPACT INFORMATION

Investigators from the Safety Board and FAA examined the wreckage at the accident scene.

The debris path was along a magnetic bearing of 330 degrees.

The accident site was located on the north slope of the Santa Monica Mountains, bordered by Mulholland Drive to the south, Ventura Blvd. to the north, Beverly Glen Blvd. to the west, and Coldwater Canyon to the east. The accident site was located directly west of Skyline Terrace Drive, a privately owned and maintained road. Skyline Terrace started at Mulholland Drive and ran north where it merged with Glenridge Drive, a public residential road. The accident site was 300 yards north of the intersection of Mulholland Drive and Skyline Terrace.

The accident site varied in slope from 45 to 70 degrees, and was densely populated with oak trees and foliage.

The initial impact crater was on a 45-degree slope with the propeller hub at the center of the crater. There was a linear impression on the ground that was dimensionally similar to the wingspan of the T28C. The impression was oriented 090- to 270-degrees and measured approximately 40 feet across. The wingspan of the accident airplane, per the North American T28C technical manual, was 40.59 feet. The left wing tip with the red navigation lens was located at the east end of the impression. The right wing tip with the navigation light housing, (missing the green navigation lens), was located at the west end of the impression.

The engine, cockpit, and the tail section of the empennage were located 50 feet downslope from the initial impact crater.

1.7 MEDICAL AND PATHOLOGICAL INFORMATION

The Los Angeles County Coroner completed an autopsy. The FAA Toxicology and Accident Research Laboratory performed toxicological testing of specimens of the pilot. The results of analysis of the specimens were negat...