N77215

HISTORY OF FLIGHT

On January 12, 2007, about 1107 Pacific standard time, a Cessna CitationJet CE-525, N77215, collided with the terrain shortly after takeoff from Van Nuys Airport, Van Nuys, California. Sunquest Executive Air Charter was operating the airplane under the provisions of 14 Code of Federal Regulations Part 91. The airline transport pilot and the commercial certificated second pilot were killed; the airplane was destroyed by impact damage and post-crash fire. The local positioning flight was departing with a planned destination of Long Beach, California. Visual meteorological conditions prevailed, and an instrument flight rules (IFR) flight plan had been filed.

The airplane had been parked overnight on the ramp of Millionaire Aviation. Two ramp workers for Millionaire indicated that they put 190 gallons of fuel in each wing. Procedures at Millionaire did not allow engine start at the fuel pumps, so after the airplane was fueled, it was towed to the start up area. One of the ramp workers had known the first pilot for some time, and reported that the first pilot was in the left seat. He also noted that it took longer than normal for the airplane to start and request marshalling out of the ramp area (about 10 minutes).

The other Millionaire worker reported that he fueled the left wing, and said that he conversed with the second pilot as he did so. He observed the second pilot open the left nose baggage door, and put one to three cases in the compartment. He informed the second pilot that he would have to move the airplane to a different location for start up. He observed the second pilot then shut the baggage door, but not lock or latch it. The worker stated that he then left to marshal out another airplane. He returned to marshal out the CitationJet, and noted that the crew had taken longer than normal to get ready for taxi. The worker was not sure of the pilots' seating arrangement.

The airplane then taxied the full length of the airport to the approach end of runway 34L, which is 8,001 feet long.

A certified flight instructor (CFI) was in an airplane that had landed on runway 34R, and was holding between runways 34R and 34L on taxiway F. The CFI stated that the airplane pitched up as it passed in front of him, and then quickly reduced pitch. It appeared to him that the airplane was low at this point, only about 100 feet above ground level (agl). The airplane then leveled off for a couple of seconds; he felt that this was in an attempt to gain airspeed and control. The CFI stated that the airplane tried to gain altitude one last time however, the airplane was slow; it stalled and broke to the right.

Witnesses at midfield noted that the airplane was airborne, and the front left baggage door was closed.

Witnesses near the end of the runway said that the front left baggage door was open, and standing straight up. The airplane was about 200 feet agl.

All of the witnesses stated that the airplane turned slightly left, leveled off, and was slow. It began descending, and the wings were slightly rocking. Several of the witnesses felt that the airplane stalled, and made a hard right turn.

The pilot of a Cessna 414 reported that he departed behind the CitationJet. The 414 pilot stated that just after the tower cleared him for takeoff, one of the CitationJet's pilots indicated that they wanted to return for landing. The tower asked if they could make it back to runway 34, or did they want runway 16. They acknowledged 34. A few seconds later, the tower controller cleared them to land on any runway. The pilot of the 414 had the CitationJet in sight, and indicated that he was looking down at it, and it appeared to be slow. He saw the slight left turn, and then the hard right into the ground. He was able to maneuver away from the fireball.

Witnesses near the ground collision reported that the airplane cut one string of power lines that were perpendicular to the flight path; the falling line hit one witness in the head.

Some witnesses thought that they saw dark objects fall from the airplane, and enter the left engine. Airport personnel made two searches for foreign objects on the runway, but found nothing.

Law enforcement personnel scoured the area from the end of the runway to the crash site, and found nothing. Most of this space was an open sod field with the very high frequency omni-directional radio range (VOR) in the middle of it.

PERSONNEL INFORMATION

First Pilot

The airplane was certified for single pilot operations. The pilot had a CE-525S type rating, which allowed him to fly single pilot operations. The company's Part 135 operation's specifications allowed single pilot flight with an operable autopilot in lieu of a second pilot. The second pilot had completed the company's Part 135 training, and was qualified as second in command for Part 135 flights.

A review of Federal Aviation Administration (FAA) airman records revealed that the 72 year old pilot held an airline transport pilot certificate with a rating for airplane multiengine land. The pilot held type ratings for the B-707, B-720, B-727, L-1011, and MD-11. The pilot held a commercial pilot certificate with a rating for airplane single-engine land.

A first-class medical certificate was issued on May 11, 2006. It had the limitations that the pilot must wear corrective lenses for near and distant vision.

The operator reported that the pilot had a total flight time of 38,000 hours in all aircraft with 800 hours in this make and model. The pilot successfully completed a flight review on December 5, 2005.

Second Pilot

A review of FAA airman records revealed that the 49 year old second pilot held a commercial pilot certificate with ratings for airplane multiengine land and instrument airplane, and a private pilot certificate for airplane single-engine land.

A first-class medical certificate was issued on July 12, 2006. It had the limitation that he must wear corrective lenses.

The operator reported that the second pilot had a total flight time of 1,693 hours in all aircraft, but was unable to provide the total flight time in the accident airplane make and model. The second pilot successfully completed a flight review on August 23, 2006.

AIRCRAFT INFORMATION

The airplane was a Cessna CitationJet CE-525, serial number 525-0149. The operator reported that the airplane had a total airframe time of 3,001.9 hours at the last inspection. They maintained the airplane on a phase inspection program. The last inspection occurred on December 15, 2006.

One item on the inspection sheet required an operational check of the door warning system for the nose baggage, tail cone baggage, and entry doors. This required opening each door individually and verifying annunciator illumination, and that no individual switches failed closed. A maintenance technician initialed completion of the check.

The left engine was a Williams International FJ44-1A, serial number 1301. Total time recorded on the engine at the last phase inspection was 3,001.9 hours.

The right engine was a Williams International FJ44-1A, serial number 1308. Total time recorded on the engine at the last phase inspection was 3,001.9 hours.

WRECKAGE AND IMPACT INFORMATION

Evidence gathered at the accident site indicated that the wings were nearly vertical to the ground when the airplane hit. The right wing tip hit the street; the left wing hit a light pole, and went through a set of power lines perpendicular to the flight path. The airplane continued through a wire fence with a cinder block wall behind it, and then through another cinderblock wall with a wire fence behind it.

The first identified point of contact (FIPC) was a ground scar in the street with right wing pieces nearby. The airplane came to rest upright on a northerly heading. The main wreckage consisted of the fuselage and empennage with the right engine attached. The left engine separated, and was about 100 feet in front of the main wreckage. The furthest piece of wreckage was a main wheel, which was about 200 yards in front of the main wreckage.

The wing assembly separated from the fuselage, and fire consumed portions of it. The remnants were about 30 feet forward of the fuselage.

The forward baggage doors' design incorporates a key lock in the lower center of each door, and two latches in the left and right bottom section of the doors. There are two hinges in the upper left and right sections of the door. The handles latched the door to the door frame in the fuselage. The key would be in the horizontal position in an unlocked condition, and in the vertical position in a locked condition.

Investigators found the front left baggage door 10 feet to the right of the right engine. It sustained mechanical and thermal damage. Structure material was missing from the front leading edge and bottom of the door. The key lock was in the horizontal position. A portion of the aft handle remained attached to the door; investigators did not find the front handle. The front left door frame fragmented and separated from the airframe. Investigators recovered a small piece, about 1-foot long, of the upper frame. One hinge remained attached to that piece.

The right front baggage door separated; it was in two pieces, and had fire damage. The key lock was not in the door, and not located. Investigators found portions of the door frame; these pieces had fire damage.

The aft baggage door latch pins were extended. The key was in the vertical position.

Control continuity was established for the elevators from the elevator surface to the forward elevator bellcrank in the cockpit area, and for the left rudder cable from the control surface to the left pedal; the right cable separated in a broomstraw manner about 1 foot from rudder pedal. Both cables for the left aileron remained attached to the left aileron sector assembly, but separated near the wing root in a broomstraw manner. The right aileron control cables separated in the wing...