N731CA

HISTORY OF FLIGHT

On December 20, 2011, about 1005 eastern standard time, a Socata TBM 700, N731CA, collided with terrain following an in-flight loss of aircraft control near Morristown, New Jersey. The airplane was registered to Cool Stream LLC and was operated by the pilot. Visual meteorological conditions prevailed and an instrument flight rules (IFR) flight plan was filed for the flight from Teterboro, New Jersey (TEB) to Atlanta, Georgia (PDK). The personal flight was conducted under the provisions of 14 Code of Federal Regulations Part 91. The certificated private pilot and four passengers were fatally injured, and the airplane was destroyed. The flight originated from TEB about 0950.

On December 20, 2011, at 0700, an IFR flight plan was filed for the flight using the Direct User Access Terminal System (DUATS). The flight plan listed a cruising speed of 292 knots and an en route altitude of flight level (FL) 260. At 0930, TEB clearance delivery issued an IFR clearance to the pilot and he subsequently contacted TEB ground control at 0943 for taxi clearance. The pilot was cleared to taxi to runway 6 and at 0948 the pilot reported that he was ready for departure for runway 6. According to air traffic control (ATC) recorded communications between TEB local control, ground control, and the pilot, weather information was not requested by, nor issued to, the pilot.

During the departure climb, while passing 8,000 feet for 10,000 feet, the pilot was directed to climb and maintain 14,000 feet. The controller then advised the pilot of moderate rime icing from 15,000 feet through 17,000 feet with light rime ice at 14,000 feet. The controller asked that the pilot advise him if the icing got worse, and the pilot responded with, “we’ll let you know what happens when we get in there and if we could go straight through, it’s no problem for us.” At 0958:24, the controller directed the pilot to climb and maintain 17,000 feet and to contact New York Center (ZNY). While climbing between 12,800 and 12,900 feet, at 116 knots ground speed, the pilot acknowledged and advised that they were entering instrument meteorological conditions (IMC).

At 1002:17, the ZNY controller advised the pilot that he would be cleared to a higher altitude when ATC could provide it, and that light icing would be encountered at 17,000 feet. The pilot responded with, “I can confirm that light icing…” and stated that, “…light icing has been present for a little while and a higher altitude would be great.” The altitude of the airplane at that time was 16,800 feet and 101 knots ground speed.

At 1002:34, the pilot reported, “we’re getting a little rattle here can we ah get ah higher as soon as possible please.” The ZNY controller responded with “stand by” and coordinated for a higher altitude with an adjacent sector controller.

At 1002:59, the ZNY controller directed the pilot to climb and maintain FL200 and the pilot acknowledged. At 1004:08, the airplane reached an altitude of 17,800 feet before it turned about 70 degrees to the left and entered a descent. At 1004:29, while descending through 17,400 feet, and at 90 knots ground speed, the pilot transmitted, “and N731CA’s declaring…” No subsequent radio transmissions were heard from the pilot. The final radar return at 1005:17 was observed at an altitude of 2,000 feet, about 600 yards west of the main wreckage impact site. The previous return, recorded 9 seconds earlier, indicated 6,200 feet.

Numerous witnesses observed the airplane during the accident sequence. A consistent observation was that the airplane descended at a rapid rate, and was trailing smoke. At least five witnesses saw pieces of the airplane separate during flight or they observed the airplane descending without a wing attached.

PERSONNEL INFORMATION

The pilot, age 45, held a private pilot certificate with ratings for airplane single-engine land and instrument airplane. He reported a total flight experience of 1,400 hours on his latest second-class medical certificate application, dated July 14, 2011. The pilot’s personal logbook(s) were not located after the accident.

The pilot completed a TBM 700 two-day recurrent training course at the SIMCOM Training Center, Orlando, Florida on November 15, 2011. According to a representative from SIMCOM, ground training was accomplished that addressed the technical aspects of the installed ice protection and environmental systems, including preflight checking and testing. Normal and emergency checklist procedures were also discussed. Simulator training consisted of system checking, testing, and operation, including operating in icing conditions, at altitude, and system malfunctions. The SIMCOM representative stated that, “It is always stressed that the installed ice protection systems are intended to provide protection while departing icing conditions.”

SIMCOM training records showed that the pilot completed a similar recurrent course on November 15 and 16, 2010.

AIRCRAFT INFORMATION

The airplane was manufactured in 2005 and was equipped with a single Pratt and Whitney Canada PT6A-64 turbo-prop engine. The airplane was issued a Standard Airworthiness Certificate on September 22, 2005 and was registered to Cool Stream LLC on October 25, 2005.

The most recent annual inspection was performed on July 27, 2011. At that time, the airplane had accumulated approximately 702.0 total flight hours. The last logbook entry was recorded on November 18, 2011, at an aircraft total time of 724.6 hours.

METEOROLOGICAL INFORMATION

The public docket for this accident contains a Meteorology Factual Report and numerous attachments to support that report. All times that follow in this section are expressed in eastern standard time unless otherwise noted.

A search of the Direct User Access Terminal (DUAT), the DUATS, and Lockheed Martin Flight Services revealed that the pilot did not access weather services or receive a telephone weather briefing prior to the accident flight. It was not determined if the pilot received weather information from other sources.

The closest surface weather observation was at Morristown Municipal Airport (MMU), located about 3 miles east-northeast of the accident site at an elevation of 187 feet. The 0945 observation reported wind from 360 degrees at 8 knots with gusts to 13 knots, visibility of 10 miles or greater, ceiling overcast at 20,000 feet, temperature 6 degrees C, dew point -2 degrees C, and altimeter setting 30.17 inches of mercury. No precipitation was noted in the observation.

The 0951 surface weather observation for TEB, located about 20 miles east-northeast of the accident site at an elevation of 9 feet, included sky clear and visibility of 10 miles or greater.

The National Weather Service (NWS) Surface Analysis Chart for 1000 depicted a low pressure center near the Indiana/Ohio border with a stationary front extending east through Ohio into western Pennsylvania. A cold front extended from this point eastward through southern Pennsylvania and southern New Jersey, and continued over coastal waters. No present weather symbols were depicted in the accident region.

The portion of the Area Forecast directed toward northern New Jersey and in effect until 1000 included the following, ceilings overcast at 7,000 feet and cloud tops to FL180. The conditions between 1000 and 1600 forecasted ceilings broken at 15,000 feet. The Area Forecast Discussion issued at 0956 did not discuss any icing hazard to aircraft.

An Airmen’s Meteorological Information (AIRMET) advisory, “ZULU,” was issued at 0945 that included the area of the accident site. The AIRMET advised of moderate icing between the freezing level (identified as located between 2,000 feet and 8,000 feet) and FL200.

Prior to the 0945 AIRMET ZULU, an amended AIRMET ZULU was issued at 0645. The amended AIRMET advised of moderate icing between the freezing level (identified as located between 3,000 feet and 9,000 feet) and FL180.

Pilot reports made over New Jersey, southern New York, and eastern Pennsylvania between 0800 and 1300 were reviewed by investigators. More than 80 reports were compiled.

An urgent pilot report was received at 0749 from a pilot operating a Cessna Citation at 14,000 feet, about 15 nautical miles southwest of Modena, Pennsylvania. The pilot reported moderate to severe rime icing between 13,000 and 14,000 feet.

An urgent pilot report was received at 1042 from “multiple” types of aircraft at 14,000 feet near Schooley’s Mountain, New Jersey. The report included severe rime icing between 14,000 and 17,500 feet.

An urgent pilot report was received at 0808 from a flight crew operating a McDonnell Douglas MD-83 aircraft at 14,000 feet over MMU. The pilot reported moderate to severe rime icing between 14,000 and 16,500 feet. One of the flight crewmembers reported that the icing was the worst he had seen in 38 years of flying experience and that he had never seen ice accumulate so quickly. He described “golf ball-sized” accumulation on the windshield wiper.

An interview with the captain of a Bombardier CRJ aircraft that was operating close to the accident aircraft reported that the wing anti-ice system could not “keep up” with the accumulation. He estimated 2.5 inches of ice on the protected areas of the wing, and 4 inches accumulation on some unprotected areas in a time span of about five minutes.

WRECKAGE AND IMPACT INFORMATION

The airplane impacted the paved surfaces and a wooded median on Interstate Highway 287, about 1 mile south of Morristown. The point of initial impact of the main wreckage was in the southbound lanes, at coordinates 40 46.573 north, 074 28.624 west. The main wreckage debris field was oriented on a heading of about 070 degrees and was about 350 feet in length. The propeller assembly separated from the engine during impact and came to rest in a wooded area on the east side of the northbound lanes.

A post-crash fire was evident on the highway and in the wooded median, where...