N4267R

HISTORY OF FLIGHT On November 19, 2012, about 0618 local time (2018 November 18 Universal Coordinated Time), a Piper PA-32-300, N4267R, was destroyed when it impacted airport terrain during an attempted turnback immediately after takeoff from Francisco C. Ada/Saipan International Airport (PGSN), Obyan, Saipan, Northern Mariana Islands, a United States territory. One passenger sustained fatal injuries, the pilot and four passengers sustained serious injuries, and one passenger sustained minor injuries. The on-demand charter flight was operated by Star Marianas Air, Inc. (SMA), under the provisions of Title 14 Code of Federal Regulations Part 135. Dawn visual meteorological conditions prevailed, and no Federal Aviation Administration (FAA) flight plan was filed for the flight.

According to a representative of the airline, the airline typically shuttled tourists between Saipan and Tinian, an island about 10 minutes' flying time south of Saipan. The passengers on the accident flight included five Chinese nationals and one Filipino national, and the flight was destined for Tinian.

According to information from the FAA and Serco, the PGSN air traffic control tower (ATCT) service provider, the pilot first contacted the ATCT at 0604, requesting taxi clearance. The flight was instructed to taxi to the end of runway 7, and was cleared for takeoff about 4 minutes later. About 4 minutes after takeoff, the pilot radioed the ATCT that he wanted to "come back in for an immediate landing if possible." About 3 minutes later, the airplane landed uneventfully on runway 7, and exited the runway at taxiway B. The pilot briefly ran up the engine, and about 3 minutes after landing, informed the ATCT that he was ready for an intersection departure from runway 7. About 45 seconds after that, the airplane was observed turning back to the left, and some garbled radio transmissions were received from the airplane. Shortly thereafter, the airplane impacted airport property near the northeast end of runway 6, a smaller parallel runway situated northwest of runway 7.

The bulk of the airplane came to rest at the treeline northwest of runway 6, and a post-accident fire began. The pilot and most passengers exited or were helped from the airplane, but the female passenger seated in the front right seat remained in the airplane, and was fatally injured.

About 2 days after the accident, the wreckage was examined on scene by personnel from the FAA, and was then recovered to a secure location.

PERSONNEL INFORMATION

Pilot Experience and Medical Information

FAA and airline information indicated that the pilot held a commercial pilot certificate, with an instrument airplane rating. The pilot began flying for SMA in January 2012. The airline initially qualified the pilot for "PIC" (pilot-in-command) authority in the PA-32-300 on January 11, 2012, and for flight instructor/check airman authority in the airplane on February 3, 2012. His most recent flight review was completed in January 2012, and his most recent FAA first-class medical certificate was issued in August 2012.

The pilot had a total flight experience of about 1,238 hours, including about 674 hours in the accident airplane make and model. Airline records indicated that the pilot had flown about 54 hours in October 2012, and about 31 hours in November, the month of the accident. According to the airline's records, the pilot was on duty from 0200 to 0500 on November 15, and did not have another duty period until 1900 on November 17. He was then on duty for 11 hours, had a rest period of 12 hours and 40 minutes, and then went back on duty at 1840 the evening before the accident. At the time of the accident, the pilot had been on duty for almost 12 hours.

The FAA Civil Aeromedical Institute conducted forensic toxicology examinations on "blood, serum" specimens from the pilot, and reported that no carbon monoxide, ethanol, or any screened drugs were detected.

Pilot Flight Recollections

A brief telephone interview was conducted with the accident pilot about 2 weeks after the accident. The pilot remembered most of the accident flight, including events leading up to it, but he had no recollection of the takeoff and return just prior to the accident takeoff.

According to the pilot, the flight/load manifest was satisfactory, and he did not note any defects during his preflight inspection, taxi-out, or engine runup. The initial takeoff and climbout was normal, but when the airplane reached an altitude of about 400 to 500 feet above ground level (agl), he noticed a "significant change" in engine sound and power. He observed that the manifold pressure and rpm gauges did not indicate full takeoff power, but stated that the engine gauges in the airline's fleet are "never accurate." He did not observe any unusual instrument indications, but his sense was that the engine's power and sound was less than that normally experienced for the indicated power settings.

Upon sensing the power loss, the pilot immediately pushed the throttle, propeller, and mixture controls full forward, but the power continued to decrease. The pilot then turned on the electric fuel boost pump, and switched the fuel selector valve from the left to the right tank.

The pilot stated that because he had conducted an intersection takeoff, he did not believe that there was enough runway remaining to land on, and he was therefore faced with the choice of putting the airplane in the ocean ahead, or attempting a turnback for landing on the airport property. He decided to attempt a turnback, and was cognizant of the decreasing power, airspeed, and altitude, as well as the danger of stalling. Initially the pilot intended to land on runway 24, but he overflew that, and then decided to try to land on the ramp. He said that he maintained a bank angle of about 35 to 45 degrees in the turn, but when the airplane was about 15-20 feet above the ground, the airplane suddenly "dropped to the ground." That was the last item he recalled about the accident sequence.

When asked about the air turnback, landing, and runup that he had conducted just prior to the accident takeoff, the pilot recalled such an event, but he could not recall whether that event was the night before, or 2 weeks prior to, the accident flight. Regarding that event, the pilot recalled that on departing Saipan, he experienced a "slight power loss" of about 100 rpm, but was able to climb to 1,500 feet on the right downwind traffic pattern leg, and therefore, elected to return to the departure runway. He "landed long," but otherwise normally. He exited the runway, leaned the mixture to "clean the plugs," conducted an engine runup, and determined that the airplane was "fine." The pilot then departed uneventfully, and landed successfully at Tinian, where he informed maintenance or company personnel about the engine event.

When informed during a telephone interview with NTSB and FAA personnel that the ATCT records indicated that he had conducted a successful air turnback just prior to the accident, again the pilot had no specific recollection of that event. The pilot did not reconcile his lack of recollection of a previous turnback with his recollection that he had conducted an intersection takeoff during the accident flight.

AIRCRAFT INFORMATION

General Information

The airplane was manufactured in 1969, and was equipped with a Lycoming IO-540 series engine. It was an all-metal low-wing monoplane design with fixed, tricycle-style landing gear. The airplane seated seven persons in a 2-3-2 arrangement from front to back. The cabin was equipped with two entrance doors, one on the front right side (for pilot and co-pilot/front seat passenger), and one at the left rear for the other five passengers. The airplane had two baggage compartments, one forward and one aft.

Flap positions include retracted (up/0 degrees), 10, 25, and 40 degrees, and were selected by moving the flap handle to one of the corresponding pre-select notches. The flaps were spring-loaded to the retracted position.

Fuel System and Usage Procedures

The airplane was equipped with four individually-selectable fuel tanks; left tip/aux, left main, right main, and right tip/aux. Total fuel capacity was 84 gallons. The four-position wing flaps were manually actuated via a cockpit handle and torque tube arrangement.

The manufacturer's Owner's Handbook (OH) specified that for takeoff, the fuel selector valve should be set to the "fullest main tank." The OH specified that once in cruise, "in order to keep the airplane in best lateral trim...the fuel should be used alternately from each tip tank" until the tip tank quantities were "nearly exhausted." At that point the OH specified switching to the main tanks.

Maintenance Information

According to the maintenance records, the airplane had accumulated a total time (TT) in service of about 6,805 hours at the time of the accident. An overhauled engine was installed in July 2012, when the airplane had a TT of about 6,290 hours.

The airline maintained the airplane on a progressive, cyclic inspection program which included four elements or segments, designated as "AAIP-1" through "AAIP-4." The most recent completed inspection cycle was the AAIP-1, which was completed on November 17, 2012, at an airframe TT of about 6,799 hours, and an engine time since overhaul of about 516 hours.

METEOROLOGICAL INFORMATION

The PGSN 0554 automated weather observation included winds from 060 degrees at 10 knots, visibility 10 miles, scattered clouds at 2,000 feet, broken cloud layer at 5,000 feet, overcast cloud layer at 11,000 feet, temperature 27 degrees C, dew point 23 degrees C, altimeter setting of 29.91 inches of mercury.

COMMUNICATIONS

PGSN was equipped with an ATCT that was operating at the time of the accident, and was operated and staffed under contract to the FAA by Serco Management Services, Inc. A transcript of the communications between the ATCT...