N497E

HISTORY OF FLIGHTOn March 27, 2014, at 0147 Pacific daylight time, a Bell OH-58A, N497E, collided with a highway near Tehachapi, California, after encountering instrument meteorological conditions (IMC). The helicopter was registered to, and operated by, the Kern County Sheriff's Department as a public aircraft flight. The commercial pilot, tactical flight officer (TFO), single passenger, and a dog from the Sheriff's K-9 division were not injured. The helicopter sustained substantial damage during the accident sequence. The cross-country flight departed Meadows Field Airport, Bakersfield, California, at 0121, with a planned destination of General William J Fox Airfield, Lancaster, California. Marginal visual meteorological conditions prevailed at the accident site, and a company flight plan had been filed.

The purpose of the flight was to transport the dog to an urgent care facility in Lancaster, after it was shot while on duty about 3 hours prior to the accident. According to the K9 Unit Supervisor, the local veterinarian could not perform treatment due to the nature of the dog's injuries.

The pilot stated that he arrived at the Air Support Unit (ASU) headquarters in Bakersfield about 0100, and was briefed on both the mission and en route weather by the current on-duty command pilot (who was coming to the end of his shift). The accident pilot confirmed that visual meteorological conditions (VMC) prevailed at both the departure and arrival airports. He was aware that a weather front was moving through the area, and that he would most likely encounter instrument meteorological conditions (IMC) while en route. He planned to use Tehachapi airport, about 45 miles east of Bakersfield, as an alternate landing site should conditions deteriorate.

At 0120, they loaded the dog into the rear left footwell, along with the K-9 Division Chief who was seated in the rear right seat. The departure was uneventful, but as they approached Tehachapi they encountered light rain, strong winds, and low clouds. Both the pilot and the TFO were wearing Night Vision Goggles (NVG's) throughout the flight.

The pilot decided to proceed, and wanted to see if Sand Canyon, east of Tehachapi, was passable. However, once they got beyond the lights of the city, he lost visual reference after flying into what he thought was clouds. He reported flying about 500 feet above ground level (agl) at that time, and was concerned that returning might cause them to collide with wind turbines and other obstacles in the area. He elected to slow the helicopter and initiate a gradual descent with the hope of exiting the clouds. During the descent he realized that the windshield had fogged up, and he turned on the demister. A short time later a highway came into view and the helicopter struck the ground.

The TFO reported similar observations stating that as soon as they launched, cloud cover started to descend into the area, and he could see clouds in the mountain passes ahead. They maintained visual contact along the route but as they approached Tehachapi, the area became further enveloped in clouds. The cloud deck at their location was about 600 feet agl and he could neither see a break nor an exit route. Looking ahead towards the northeast he observed the cement plant at Monolith, and a break in the clouds beyond near Highway 58. He communicated this to the pilot, and as they flew past the cement plant, his forward vision became completely obscured. He could still see out of the side window, so assumed the windshield had fogged up (it often did during rain because of a leak). The pilot then turned on the demister, and the TFO perceived that the helicopter was now performing gradual S-turns over the highway. He did not get the sense that they were descending, and he continued to look out of the right window, telling the pilot that they were clear of obstructions. He continued to move his head back and forth observing the front and side windows; however, the front windshield was still obscured. A few seconds later he looked out of the right window, and although he could not sense movement, they appeared to be rapidly descending. They transitioned over the eastbound lanes of the highway, and he immediately called for the pilot to pull up, however, a few seconds later the helicopter struck the ground.

The helicopter struck the surface of the westbound lane of Highway 58, bounced back into the air, and rotated about 180 degrees. The pilot maintained a low hover and could now see the lights of Tehachapi ahead. The helicopter appeared to be handling normally, and was not vibrating or making any unusual sounds, so he elected to return to Tehachapi Airport, 5 miles to the west. Before landing he asked the TFO to open the door to observe the skids; they appeared intact. The TFO attempted to utilize the Forward Looking Infrared Camera (FLIR) mounted on the nose, and rear-mounted "Nightsun" searchlight to assist with the landing, but they were both inoperative. The helicopter then landed uneventfully.

Subsequent examination revealed that the helicopter sustained substantial damage to the belly structure, with the skids having been spread about 2 feet beyond their normal stance. The FLIR and searchlight were both disabled, and sustained crush damage to their lower cowlings, and the tailskid appeared to have struck the ground.

The helicopter was equipped with an AeroComputers Digital Mapping System. The system recorded the helicopters GPS track at approximately 1-second intervals. The data for the accident flight revealed a track that closely matched the crew's statements. The helicopter maintained a southeast track for the majority of the flight, generally following Highway 58. The projected flight track beyond the accident site would have taken the helicopter through a pass which was flanked immediately to the north and south by wind turbine-covered peaks, at elevations ranging between 1,000 and 2,000 ft above the highway. PERSONNEL INFORMATIONThe pilot was the chief flight instructor for the ASU. He stated that he had been flying fixed wing aircraft since 1975, and helicopters since 1980. His flight experience was primarily within the fields of electronic news gathering, emergency medical service, and law enforcement. He held an airline transport pilot certificate with ratings for helicopter-rotorcraft, along with a commercial certificate with ratings for airplane single engine land, multiengine land, and instrument airplane. He also held a flight instructor certificate with ratings for helicopter. He reported a total flight experience in all aircraft of 16,110 hours, with 6,193 in the accident make and model. He had flown for 14 hours during the preceding 30 days, three of which were in the accident make and model.

The pilot held a second-class medical certificate issued on September 24, 2014. It had no limitations or waivers.

The TFO did not hold a pilots certificate.

The pilot submitted a sleep and activity log for the 72-hour period leading up to the accident. Each day he went to sleep at 2130, and woke at 0530. Although he was on duty from 0800 to 1600 on both prior days, he did not fly on the day before the accident. He was awakened by a phone call from the ASU at 0015 on the day of the accident, and reported for duty at 0100. AIRCRAFT INFORMATIONThe helicopter was manufactured by Bell Helicopters in October 1970 and delivered to the United States Army at the end of that month. After being retired from military service, it was purchased by the Kern County Sheriff's Department in June 1997. According to the Sheriff's Department, the helicopter had accrued 8,036 hours of total flight time on the date of the accident.

The helicopter was maintained utilizing the manufacturer's inspection program, the last inspection of which occurred on March 17, 2014, 36 flight hours prior to the accident.

The helicopter was not equipped with instruments certified for instrument flight rules; it was equipped with a radar altimeter. METEOROLOGICAL INFORMATIONThe closest weather reporting station was located at Tehachapi. Five minutes before departure it reported wind from 300 degrees at 15 knots with gusts to 22 knots, 7 miles visibility, broken ceiling at 500 ft agl, overcast skies at 1,300 ft agl, temperature 4 degrees C, dew point temperature 4 degrees C, altimeter 29.93 inHg.

At 0135, the visibility remained the same, with scattered clouds at 400 ft agl, broken ceiling at 800 ft agl, and overcast skies at 1,700 ft agl.

Next Generation Radar (NEXRAD) LEVEL-II data imagery for the period 1245 to 0158 revealed rain showers forming and moving eastward into the mountainous terrain east of Bakersfield.

An area forecast, issued about 6 hours prior to the accident, indicated rain showers and ceilings near 3,000 ft for Bakersfield, along with isolated showers for the mountains and 20 knots wind, gusting to 30 knots. An AIRMET was also issued about that time indicating mountain obscuration and turbulence. AIRPORT INFORMATIONThe helicopter was manufactured by Bell Helicopters in October 1970 and delivered to the United States Army at the end of that month. After being retired from military service, it was purchased by the Kern County Sheriff's Department in June 1997. According to the Sheriff's Department, the helicopter had accrued 8,036 hours of total flight time on the date of the accident.

The helicopter was maintained utilizing the manufacturer's inspection program, the last inspection of which occurred on March 17, 2014, 36 flight hours prior to the accident.

The helicopter was not equipped with instruments certified for instrument flight rules; it was equipped with a radar altimeter. ADDITIONAL INFORMATIONNight Vision Goggles

All ASU pilots received training in the use of NVG's during the period from 2006 through 2009 by Aviation Specialties Unlimited of Boise, Idaho. All subsequent recurrent training was performed by both the accident pilot and the deputy flight i...